J. A. Roby ultimate 2015 Instruction Manual Download Page 2

Page: 2 / 29

Table of Content

Introduction ...................................................................... 3

Nameplate. ...................................................................... 4

Appliance Dimension. ...................................................... 5

Specifications. ................................................................. 5

Installation. ...................................................................... 6

Floor protection. ................................................................... 6

Floor protection plate minimum dimensions. ................... 6

Clearances of the stove until the floor plate protection. ... 6

Minimums clearances to combustible material. .................... 7

Assembly before installation ............................................ 8

Legs installation. .............................................................. 8

Fan and Snap disc box installation. ................................. 8

Firebricks installation............................................................ 9

Floor firebricks installation. .............................................. 9

Back firebricks installation. .............................................. 9

Side firebricks installation .............................................. 10

Firebricks installation on the pipes. ................................ 10

General stove installation steps. .................................... 12

Chimney connector installation. ......................................... 13

Chimney installation, General steps ................................... 14

Inside Masonry Chimney, Vertical Installation ............... 15

Outside Vertical Installation. .......................................... 15

Cathedral Vertical Installation ........................................ 15

Offset Installation ........................................................... 16

Vertical Installation......................................................... 17

External combustion air source. .................................... 18

Exterior Air Intake pipe. ................................................... 18

Installation of Air Intake Pipe. ........................................ 18

Air Inlet Obstruction ....................................................... 18

Stainless steel deflector replacement................................. 19

Front deflector Add-on Replacement. ............................ 19

Stainless steel tubes Installation. ................................... 19

Tube support installation. ................................................... 20

Operating Instructions ................................................... 21

Primary and secondary air admission control. ............. 21

Lightning fire. ................................................................... 21

First fire. ............................................................................. 21

Keep a fire. ........................................................................ 21

Fans Controls. ................................................................... 22

Wood storage .................................................................... 22

Maintenance. ................................................................. 22

Ash Removal. .................................................................... 22

Ash Disposal. ..................................................................... 22

Creosote Formation. .......................................................... 22

Chimney Inspection. .......................................................... 22

Chimney Sweeping. ........................................................... 23

Door care. .......................................................................... 23

Air Tighten Adjustment. ...................................................... 23

Door adjustment (hinges side). ...................................... 23

Door adjustment (right side) .......................................... 23

Cleaning up glass .......................................................... 23

Uninstalling and installing door. ..................................... 23

Broken glass replacement. ............................................ 23

Fiberglass rope replacement. ........................................ 24

What to do in case of Chimney Fire. .............................. 24

Appendix 1..................................................................... 25

Door assembly ................................................................... 25

Square Door .................................................................. 25

Arc Door ........................................................................ 26

10.

Appendix 2 ................................................................ 27

Fans electric wiring diagram. ............................................. 27

Therm-O-disk Box parts description. .................................. 27

11.

Appendix 3 ................................................................ 28

Parts that can be replaced ............................................. 28

12.

J. A. ROBY LIMITED LIFE WARRANTY – WOOD

BURNING STOVES & FIREPLACES..................................... 29

Summary of Contents for ultimate 2015






























Search results

Summary of Contents for ultimate 2015

Reviews:

Related manuals for ultimate 2015

Brands by name

Popular brands

J. A. Roby ultimate 2015, Instruction Manual

Search results

Summary of Contents for ultimate 2015

Reviews:

Related manuals for ultimate 2015

Brands by name

Popular brands