HTI 1437137, Instruction Manual

Page: 5 / 6

P. 7
P. 8
TROUBLESHOOTING GUIDE
•PROBLEM: THE QUAD DOES NOT RUN.
PROBLEM CAUSE: The battery may be low on power.
After each use, or once a month minimum, charge the battery for 8-12 hours. Do not leave the battery on charge for more
than 20 hours.
POSSIBLE CAUSE: Thermal fuse has tripped.
The Quad is equipped with a self-resetting fuse. When the Quad is overloaded or operated incorrectly; the self-resetting
fuse will be cut off for 60 seconds before becoming operational again. The self-resetting fuse is under the seat (Refer to the
picture.)
POSSIBLE CAUSE: Battery connector or wires are loose.
Make sure the battery connectors are firmly plugged into each other.
POSSIBLE CAUSE: Battery is dead.
Have you properly maintained the battery according to the directions? Is the battery old? Your battery may need to be
replaced.
POSSIBLE CAUSE: Electric system is damaged.
Water may have corroded the system, or loose dirt, gravel or sand might have jammed the switch.
POSSIBLE CAUSE: Motor is damaged.
The motor needs professional repair.
•PROBLEM: THE BATTERY WILL NOT RECHARGE.
POSSIBLE CAUSE: Battery connector or adapter connector is loose.
Make sure the battery connector and adapter connector are firmly plugged together.
POSSIBLE CAUSE: Charger is not plugged in.
Make sure the charger is plugged into the wall outlet and the power flow to the outlet is on.
POSSIBLE CAUSE: Charger is not working.
Is the charger warm while charging? If not, the charger may not work properly and may need to be replaced.
•PROBLEM: THE QUAD DOES NOT RUN VERY LONG.
POSSIBLE CAUSE: Battery may be undercharged.
You may not be charging the battery long enough. After each use, or once a month minimum, charge the battery for
8 to 12 hours. Do not leave the battery on charge for more than 20 hours.
POSSIBLE CAUSE: Battery is old.
The battery will eventually lose the ability to hold a charge. Depending on the amount of use, and varying conditions
the battery should operate for one to three years. Replace the battery with a new one.
• PROBLEM: BATTERY BUZZES OR GURGLES WHEN CHARGING.
This is normal and not a cause for concern. It may also be silent when charging, which is also normal.
• PROBLEM: CHARGER FEELS WARM WHEN RECHARGING BATTERY.
This is normal and not a cause for concern.
Fuse: 5A
Battery
To avoid the fuse cut off the power,
follow these guidelines:
DO NOT overload the Quad,
Maximum weight allowed: 25 kg
DO NOT tow anything behind the Quad.
DO NOT drive up steep slopes.
DO NOT drive into fixed objects, which may cause the
wheels to spin, causing the motor to overheat.
DO NOT drive in very hot weather, components may
overheat.
DO NOT tamper with the electric system, doing so may
create a short circuit, causing the fuse to trip.
MAINTAINING THE QUAD
• It is the parents' responsibility to check main parts of the Quad before using, must regularly examine for damage, such as
the battery, charger, cable or cord, plug, screws or enclosure and other parts and that in the event of such damage, the
Quad must not be used until that damage had been properly repaired.
• Make sure the plastic parts of the Quad are not cracked or broken.
• Occasionally use a lightweight oil to lubricate moving parts such as wheels.
• Park the Quad indoors or cover it to protect it from wet weather.
• Keep the Quad away from sources of heat, such as stoves and heaters. Plastic parts may melt.
• Recharge the battery after each use. Only an adult can handle the battery. Recharge the battery at least once a month
when the Quad is not being used.
• Do not wash the Quad with a hose. Do not wash the Quad with soap and water. Do not drive the Quad in rain or snowy
weather. Water will damage the motor, electric system and battery.
• Prior to swipe clean the Quad, disconnect the battery charger from the toy. Clean the Quad with a soft, dry cloth. To restore
shine to plastic parts, use a non-wax furniture polish. Do not use car wax. Do not use abrasive cleaners.
• Do not drive the Quad in loose dirt, sand or fine gravel which could damage moving parts, motors or the electric system.
• When not using, all the electrical source should be off. Turn off the power switch and disconnect the battery connection.
DISPOSAL OF BATTERY
● Your sealed lead-acid battery must be recycled or disposed of in an environmentally sound manner.
●
Do not dispose of your lead-acid battery in a fire. The battery may explode or leak.
● Do not dispose of a lead-acid battery in your regular, household trash. The incineration, land filling or mixing of sealed
lead-acid batteries with household trash is prohibited by law.
●
Return an exhausted battery to your local approved lead-acid battery recycle, such as a local seller of automotive
batteries.
●
Contact your local waste management officials for other information regarding the environmentally sound recycling and
disposal of lead-acid batteries.
● The battery must be charged only by adult .Please charge the product before using!
●
The toy should not be connected to excessive powers (more than the quantity specified herein), and it should not be
operated during charging process.
●
Any rechargeable battery must only be charged under adult's supervision.
● Battery charger should regularly check the wires, plugs, casing and other parts for damage and if found should stop using
and restored.
●
All batteries should be inserted with the correct polarity (+ and -).
● The battery charger used with the toy are to be regularly examined for damage to the cord, plug, enclosure and other
parts, in the event of such damage, they must not be used until that damage had been repaired.