Periodic Service
10-18
Refer to SEA J1034 standard, more
specifically also to SAE J814c.
IMPORTANT:
When the antifreeze is mixed with water, the
antifreeze mixing ratio must be less than
50%.
VOL%
Anti-freeze
Freezing point
Boiling point
℃
°
F
℃
°
F
40 -24
-12
106
222
50 -37
-34
108
226
*At 1.013×10
5
Pa (760mmHg) pressure (atmospheric).
A higher boiling point is obtained by using a
radiator
pressure cap which permits the development of
pressure within the cooling system.
5. Adding the LLC
1) Add only water if the mixture reduces in
amount by evaporation.
2) If there is a mixture leak, add the LLC of the
same manufacturer and type in the same
mixture percentage.
* Never add any long-life coolant of different
manufacturer.(Different brands may have
different additive components, and the
engine may fail to perform as specified.)
6. When the LLC is mixed, do not employ any
radiator cleaning agent. The LLC contains
anticorrosive agent. If mixed with the
cleaning agent, sludge may build up,
adversely affecting the engine parts.
7.
The vehicle’s genuine long-life coolant has a
service life of 2 years. Be sure to change the
coolant every 2 years.
NOTE:
The above data represent industry
standards that necessitate a minimum glycol
content in the concentrated antifreeze.
When the coolant level drops due to
evaporation, add water only to keep the
antifreeze mixing ratio less than 50%. In
case of leakage, add antifreeze and water in
the specified mixing ratio before filling into
the radiator.
■
Replacing Radiator Hose (Water pipes)
Replace the hoses and clamps.
(See “Checking Radiator Hose and Clamp” in
“EVERY 200 HOURS” in “PERIODIC SERVICE”
section.)
■
Replacing Fuel Hose
Consult your local HUANSONG Dealer for this
service.
■
Replacing Brake Master Cylinder (Inner
parts)
Consult your local dealer for this service.
■
Replacing Front Brake Seal
Consult your local dealer for this service.
■
Replacing Rear Brake Cylinder Seal
Consult your local dealer for this service.
■
Replacing Intake Air Line
Consult your local dealer for this service.
EVERY 4 YEARS
■
Replacing Brake Hose
Consult your local Dealer for this service.
■
Replacing Slow-Blow Fuses
The slow-blow fuses are intended to protect the
Summary of Contents for HS 400-4
