Introduction and Safety
4
Owner’s Manual for MWT500 Water Trailer
•
DO NOT
drive over hoses while pressurized or
while pump is running.
•
NEVER
leave unit unattended while pump is
running.
•
DO NOT
start a unit that needs repair.
Towing Safety
Towing a trailer requires care. Both the trailer and vehicle
must be in good condition and securely fastened to each
other to reduce the possibility of an accident. Some states
require large trailers to be registered and licensed. Contact
your local Department of Transportation office to check on
license requirements for your particular unit.
Hitch and Coupling
•
Verify the hitch and coupling on the towing vehicle
are rated equal to, or greater than, the trailer's
Gross Vehicle Weight Rating (GVWR).
•
Verify the trailer hitch and the coupling are
compatible. Make sure the coupling is securely
fastened to the vehicle.
•
DO NOT
tow trailer using defective parts. Inspect
the hitch and coupling for wear or damage.
•
Connect safety chains in a crossing pattern under
the tongue.
Attach breakaway cable to rear
bumper of towing vehicle.
Do not attach cable to
trailer hitch.
•
Before towing the trailer, verify the weight of the
trailer is equal across all tires. On trailers with
adjustable height hitches, adjust the angle of the
trailer tongue to keep the trailer as level as
possible.
Running Lights
Verify directional and brake lights on the trailer are
connected and working properly.
Wheels and Tires
•
Check trailer tires for wear and proper inflation.
Safe Towing Techniques
•
Practice turning, stopping, and backing up in an
area away from heavy traffic prior to transporting
the unit.
•
Maximum recommended speed for highway towing
is 45 mph (72 km/h). Recommended off-road
towing speed is 10 mph (16 km/h) or less,
depending on terrain.
•
When towing, maintain extra space between
vehicles and avoid soft shoulders, curbs, and
sudden lane changes.
Reporting Trailer Safety Defects
If you believe your trailer has a defect which could cause
a crash or could cause injury or death, you should
immediately inform the National Highway Traffic Safety
Administration (NHTSA) in addition to notifying Generac
Mobile Products LLC.
If NHTSA receives similar complaints, it may open an
investigation; and if it finds that a safety defect exists in a
group of vehicles, it may order a recall-and-remedy
campaign. However, NHTSA cannot become involved in
an individual problem between you, your dealer, or
Generac Mobile Products LLC.
To contact NHTSA, you may either call the Auto Safety
Hotline toll-free at 1-888-327-4236 (TTY:1-800-424-9153),
go to
www.safercar.gov
; or write to:
Administrator
NHTSA
1200 New Jersey Avenue S.E.
Washington, DC 20590
You can also obtain other information about motor vehicle
safety from
www.safercar.gov
.
WARNING
Personal injury. Trailer must be securely coupled to
the hitch with the chains correctly attached. Uncoupled
or unchained towing could result in death or serious
injury.
(000233a)
WARNING
Property or Equipment Damage. Tighten wheel lug
nuts after first 50 miles to factory specifications.
Failure to do so could result in death, serious injury,
property or equipment damage.
(000235)
Discount-Equipment.com