Fuji Xerox apeosport-IV 6080, Administrator'S Manual

Page: 533 / 705

Paper Jams
533
Pr
o
b
lem S
o
lving
15
Paper Jams
When a paper jam occurred, the machine stops and an alarm beeps. A message is also
displayed on the touch screen. Follow the instructions displayed to remove the jammed
paper.
Gently remove the paper to avoid it to be torn. If the paper is torn, remove all the torn
pieces, making sure that none remain inside the machine.
If a paper jam message appears again after you have cleared the paper jam, another
paper jam may be occurred in some other parts of the machine. Clear this by following
the message.
When the paper jam is cleared, printing is automatically resumed from the point when
the paper jam occurred.
If you were during copying, press the <Start> button to resume the copying from the
point when the paper jam occurred.
This section describes the procedures to remove the jammed paper from the following
locations.
The following shows the reference section for the procedures to clear a paper jam in
each location.
Paper Jams in Trays 1 and 2..................................................................................................... 534
Paper Jams in Trays 3 and 4..................................................................................................... 534
Paper Jams in Tray 5 (Bypass)................................................................................................. 535
Paper Jams in Tray 6 (HCF (A4 1 Tray)) (Optional)............................................................... 537
Paper Jams in Trays 6 and 7 (HCF (A4 2 Tray)) (Optional).................................................... 539
Paper Jams at the Trays 6 and 7 (HCF (A4 2 Tray)) (Optional).............................................. 539
Paper Jams in the Transfer Module.......................................................................................... 542
Paper Jams in the Lower Left Door ......................................................................................... 547
Paper Jams in the Output Tray ................................................................................................. 547
Paper Jams in the Finisher-C1 / Finisher-C1 with Booklet Maker .......................................... 548
Paper jams in the D2-Staple-Finisher and the D2-Staple-Finisher with Booklet Maker ......... 556
Important • When a paper jam occurred, if you pull out a paper tray without checking the paper jam
location, the jammed paper may be torn and the pieces may remain inside the machine. This
may cause machine malfunctions; therefore, always check where the paper jam occurred
first.
• If any piece of jammed paper remains inside the machine, the paper jam message will not
disappear from the touch screen.
• Clear the paper jams while the machine is on. If you turn off the machine, all data stored on
the memory of the machine will be erased.
• Do not touch components inside the machine. This may cause print defects.
WARNING
If you need to pull out a tray to remove paper jam, contact your local Fuji Xerox rep-
resentative. Do not pull out a tray, otherwise it may cause injuries.
CAUTION
Do not attempt to remove a paper deeply jammed inside the product, particularly a
paper wrapped around a fusing unit or the heat roller. Otherwise, it may cause inju-
ries or burns. Switch off the product immediately and contact your local Fuji Xerox
representative.