412-03-4
412-03-4
Air Conditioning
DIAGNOSIS AND TESTING (Continued)
Symptom Chart (Continued)
Condition
Possible Sources
Action
•
DTC B2119 Compressor
•
A/C inverter motor controller
Failure
(IMC).
•
Circuit(s).
•
Interface adapter assembly
(IAA) module.
•
A/C compressor.
•
DTC B2518 Compressor
•
Overtemperature condition.
Overtemperature Fault
•
A/C compressor (A/C
overtemperature sensor).
•
Interface adapter assembly
(IAA) module.
•
DTC B2606 A/C Temperature
•
Circuit(s).
Sensor Out of Range
•
A/C compressor (A/C
overtemperature sensor).
•
Interface adapter assembly
(IAA) module.
•
A/C Compressor Does Not
•
Low refrigerant.
Operate (No Cooling)
•
Refrigerant leak.
•
A/C low pressure switch.
•
Interface adapter assembly
(IAA) module.
•
Circuit(s).
•
A/C inverter motor controller
(IMC).
•
High-voltage power
distribution box (HVPDB).
•
High-voltage A/C fuse.
Special Tool(s)
Pinpoint Tests
R-134a Manifold Gauge Set 176-R032A or equivalent
Special Tool(s)
R-12/R-134a Air Conditioning Test Fitting Set
104-Pin Breakout Box (BOB) 418-049 (014-00950) or
412-DS028 (014-00333) or equivalent
equivalent
A/C Pressure Test Adapter 412-093 (T94P-19623-E)
Capacitor Discharge Tool 418-F213
(Continued)
PINPOINT TEST A: DTC P1461 A/C PRESSURE SENSOR CIRCUIT HIGH INPUT
TEST STEP
ACTION TO TAKE
A1 CHECK A/C PRESSURE
•
With key ON, set the mode select knob to the A/C position, the
Yes =
System OK. CHECK wiring
temperature control knob to full cool position, and the blower control
for intermittent connections.
knob to HIGH speed position, and monitor the interface adapter assembly
CHECK the refrigerant
(IAA) module PID A/CPRES.
system for proper operation.
•
Is the pressure between 80 and 3275 kPa (12 and 475 psi)?
No =
If pressure is less than 80
kPa (12 psi), GO to A2.
If pressure is greater than
3275 kPa (475 psi), GO to
A3.
A2 CHECK A/C SYSTEM PRESSURE
•
Connect R-134a Manifold Gauge Set to charge ports and observe the
Yes =
A/C system pressure.
(Continued)
2001 Ranger EV, 01/2001
Summary of Contents for 2001 Ranger
