Fire Stone Home Products • Legacy Gas Grill • Rev. C
WARNING
WARNING
Figure 2
WARNING
WARNING
Lighting Instructions
Checking For LP Gas Leaks
Never test for leaks with a flame. Check for gas leaks prior
to first use, at the beginning of each season, or every time
the LPG cylinder is changed. Follow these four steps:
. Use a commercially-available non-corrosive leak check
solution.
2. Turn the grill control knob to the full OFF position, then
turn the gas ON at source.
3. Apply the leak check solution to all gas connections.
Bubbles will appear in the leak check solution if the
connections are not properly sealed. Tighten or repair
as necessary.
4. If there is a gas leak that cannot be repaired, turn off
the gas at the source, disconnect fuel line from the grill
and call the gas grill dealer, or gas supplier for repair
assistance.
Basic Lighting Procedures
. Familiarize yourself with the safety guidelines at the
front of this manual. Do not smoke while lighting grill or
checking gas supply connections.
2. Be sure the LPG cylinder is filled.
3. Make sure all gas connections are securely tightened.
4. Ensure that 2 - “D” size batteries have been installed.
5. Open the grill lid.
Lighting the Grill by Match
To light the gas grill by match, follow steps through 6 of the
Basic Lighting Procedures. Then, insert a lit match through
the lighting hole on either side of the grill (see Figure 2).
Turn the nearest control knob to the HIGH setting to release
gas. The burner should light immediately.
6. Set control knob to OFF and open the LPG cylinder
valve.
7. Push and turn ignitor control knob to HIGH. The built-in
ignitor will click and spark to ignite burner. Ignitor may
need realignment to generate adequate spark.
8. Confirm ignition by viewing flame through the convec
-
tion plate holes.
9. If the burner does not light, turn the control knob to OFF,
wait 5 minutes for gas to clear, then retry.
0. Adjust control knob to the desired cooking temperature.
Explosion Risk
Fire Risk
Failure to open the grill lid during the lighting procedures
could result in a fire or explosion which could cause
property damage, serious bodily injury or death.
Explosion Risk
Fire Risk
IF YOU SMELL GAS:
• Shut off gas supply to the grill.
• Extinguish any open flame.
• Open grill lid.
• If odor continues, immediately call your gas com-
pany or local fire department.
Failure to comply with these instructions could result
in a fire or explosion which could cause property dam
-
age, serious bodily injury or death.
Fire Risk
Explosion Risk
A strong gas smell, or the hissing sound of gas indi-
cates a serious problem with the gas grill or the LPG
cylinder.
• Get away from the LPG cylinder.
• Do not try to fix the problem yourself.
• Call the fire department. (Do not call near the LPG cyl
-
inder because the telephone is an electrical device.)
Failure to immediately follow the steps listed above
could result in a fire or explosion which could cause
property damage, serious bodily injury or death.
Hot Surfaces
•
Never
lean over the grill cooking area
while lighting the gas grill.
• Keep face and body a safe distance (at
least 18 inches) from the lighting hole or
burners, when lighting the grill by match.
