Check for leaks
ALL JOINTS AND CONNECTIONS MUST BE LEAK TESTED BEFORE
USING THE BBQ. LEAK TEST ANNUALLY, AND WHENEVER
THE GAS BOTTLE IS REMOVED OR REPLACED.
Before use please check for leaks
Never check for leaks with a naked flame, always
use a soapy water solution
1.
Make a mixed solution (water and liquid detergent / soap).
2.
Ensure that there are no naked flames, heat sources and cigarettes in
the vicinity when performing a leak test.
3.
Check that the control valve on the BBQ is ”OFF”.
4.
Connect the regulator to the cylinder and ON/OFF valve to the
burner, ensure the connections are secure then turn ON the gas.
5.
Brush the soapy solution on to the hose and all joints. If bubbles
appear you have a leak, which must be rectified before use.
6.
Retest after fixing the fault. Turn OFF the gas at the cylinder after
testing.
7.
IF BUBBLES APPEAR, SWITCH OFF THE GAS SUPPLY AND REPAIR
THE PROBLEM. PERFORM A NEW LEAK TEST. DO NOT USE THE
BBQ BEFORE YOU ARE SURE THAT THERE ARE NO LEAKS.
8.
If detected leakage cannot be rectified, do not attempt to cure
leakage but consult your gas dealer.
!
Regulator and hose
Follow these instructions carefully to avoid
serious damage your barbecue and causing injury
to yourself and to property.
HOSE
•
Connect the gas hose to the gas rail inlet on the left hand side of the
barbecue. Do not overtighten.
•
Fit the regulator and the hose. Follow the assembly instructions
supplied with the regulator set.
•
Do not use any sealing tape, paste or liquid on the connection.
•
Gas hoses used for this product must not exceed 120 cm in length
•
Check the gas hose regularly for cracks, damage and decay. Never
use a damaged gas hose.
REGULATOR
•
Confirm all barbecue control knobs are OFF
•
Connect the regulator to the gas bottle according to your regulator
and bottle dealer’s instructions.
•
We recommend propane gas for use in the Nordic Region, but butane
can also be used.Butane is not very suitable for low temperatures.
•
Check that the movable plastic collar on the regulator is intact and
that it has not been damaged by hot BBQ parts.
•
Check that the gas bottle stands on a firm, flat surface and is lower
than the connector.
•
Use an approved gas bottle that fits the regulator supplied. Bottles of
10 kg or above are recommended.
NEVER STORE THE GAS BOTTLE UNDER THE BBQ WHEN IN USE.
IF THE GAS BOTTLE IS BEING STORED UNDER THE BBQ WHEN NOT IN USE,
DISCONNECT THE REGULATOR.
NEVER MOVE THE BBQ WHILE IT IS IN USE, OR CONNECTED TO THE GAS BOTTLE.
!
15
14
