- 20 -
IMPORTANT: Water or other contaminants in fuel can
severely damage
fuel
pump and/or other engine components.
4.1.14
Glow Plug Light
(27 HP Daihatsu Diesel Only)
: Located on the console to the
right of the ignition switch. The glow plug light comes on when the ignition switch
is turned to the ON position. The glow plug light indicates the glow plugs are
preheating the combustion chamber. Wait for the glow plug light to go out before
starting the engine.
4.1.15
Warning Buzzer: Located behind the seat on the left hand side of the engine air
deflector. The buzzer is a warning signal for the following circumstances:
a) When the engine is not running and the ignition switch is turned to the ON
position, the buzzer emits intermittent beeps. The intermittent beeps remind
the user that the switch is ON and the hourmeter is running. A switch left ON
could also drain the battery.
b) When the engine is running and the buzzer emits a continuous beep, the
buzzer is warning the user that the engine is overheating. Perform the
following steps.
1. Disengage the mower blades, and idle down the engine.
2. Look at the temperature gauge to determine if temperature
continues to increase. If it does, turn the unit off and allow the
engine and engine components to cool.
3. Check the coolant level. If necessary fill with coolant as described
in Section 5.1.2.
4. Remove any debris on or around the radiator that may restrict
airflow.
c) When the engine is running and the buzzer emits intermittent beeps, the
buzzer is warning the user that the engine oil pressure is low. Perform the
following steps.
1.
Turn the unit off, allow the engine and engine components to cool.
2. Check the oil level and fill, if necessary, as described in Section
5.1.1.
3. Check for oil leaking from engine. If the engine is leaking, see
Engine Service Dealer.
4.2 PRE-START
4.2.1
Fill fuel tanks.
For 31 HP Daihatsu Gas Units:
For best results use only clean, fresh regular grade
unleaded
gasoline with an
octane rating of 87 or higher. Regular grade leaded gasoline may also be used;
however, combustion chamber and cylinder head will require more frequent
service. See Engine Owner's Manual.
For 27 HP Daihatsu Diesel Units:
For best results use only clean, fresh diesel fuel, with a cetane rating of 40 higher.
NOTE:
Do not use kerosene or gasoline instead of diesel fuel. Failure to
observe this caution will damage the engine.
For All Units:
DO NOT
add oil to gasoline.
DO NOT
overfill fuel tank. Never fill the fuel tank so that the fuel level rises
above a level that is 1/2” below the bottom of the filler neck to allow for fuel
expansion and prevent fuel spillage.
4.2.2
Make sure you understand the controls, their locations, their functions, and their
safety requirements.
4.2.3
Refer to Maintenance, Section 5, and perform all the necessary inspection and
maintenance steps.
For Exmark Mower Parts Call 606-678-9623 or 606-561-4983
www.mymowerparts.com
