background image

iv

KA369R, KA542R, AND KA57WE AUXILIARY SWITCH KIT INSTALLATION AND ADJUSTMENT INSTRUCTIONS

   MN280031EN

The instructions in this manual are not intended as a 

substitute for proper training or adequate experience in the 

safe operation of the equipment described. Only competent 

technicians who are familiar with this equipment should 

install, operate, and service it.
A competent technician has these qualifications:
• Is thoroughly familiar with these instructions.
•  Is trained in industry-accepted high and low-voltage safe 

operating practices and procedures.

•  Is trained and authorized to energize, de-energize, clear, 

and ground power distribution equipment.

•  Is trained in the care and use of protective equipment 

such as arc flash clothing, safety glasses, face shield, hard 

hat, rubber gloves, clampstick, hotstick, etc.

Following is important safety information. For safe 

installation and operation of this equipment, be sure to read 

and understand all cautions and warnings.

Safety instructions

Following are general caution and warning statements that 

apply to this equipment. Additional statements, related to 

specific tasks and procedures, are located throughout the 

manual.

Safety for life

!

SAFETY

FOR LIFE

!

SAFETY

FOR LIFE

Eaton meets or exceeds all applicable industry standards relating to product safety in its Cooper Power™ series products. 

We actively promote safe practices in the use and maintenance of our products through our service literature, instructional 

training programs, and the continuous efforts of all Eaton employees involved in product design, manufacture, marketing, 

and service.
We strongly urge that you always follow all locally approved safety procedures and safety instructions when working around 

high voltage lines and equipment, and support our “Safety For Life” mission.

Safety information

DANGER

Hazardous voltage. Contact with hazardous voltage will 

cause death or severe personal injury. Follow all locally 

approved safety procedures when working around high- 

and low-voltage lines and equipment. 

                

G103.3

WARNING 

Before installing, operating, maintaining, or testing this 

equipment, carefully read and understand the contents 

of this manual. Improper operation, handling or 

maintenance can result in death, severe personal injury, 

and equipment damage.                                            

G101.0

WARNING 

This equipment is not intended to protect human 

life. Follow all locally approved procedures and safety 

practices when installing or operating this equipment. 

Failure to comply can result in death, severe personal 

injury and equipment damage.                                  

G102.1

WARNING 

Power distribution and transmission equipment must 

be properly selected for the intended application. It 

must be installed and serviced by competent personnel 

who have been trained and understand proper safety 

procedures. These instructions are written for such 

personnel and are not a substitute for adequate training 

and experience in safety procedures. Failure to properly 

select, install or maintain power distribution and 

transmission equipment can result in death, severe 

personal injury, and equipment damage.     

      

                G122.2

This manual may contain four types of hazard statements:

DANGER 

Indicates an imminently hazardous situation which, if 

not avoided, will result in death or serious injury.

WARNING 

Indicates a potentially hazardous situation which, if not 

avoided, could result in death or serious injury.

CAUTION 

Indicates a potentially hazardous situation which, if not 

avoided, may result in minor or moderate injury.

CAUTION

Indicates a potentially hazardous situation which, if not 

avoided, may result in equipment damage only.

Hazard Statement Definitions

Summary of Contents for COOPER POWER SERIES

















Reviews: