18
DCD-510AE
TROUBLE SHOOTING
FLOW CHART NO.1
The power cannot be turned on.
㸣
Is the fuse normal?
㸢
No See FLOW CHART No.2 <The fuse blows out.>
㸣
Yes
Is normal state restored when once unplugged power cord
is plugged again after several seconds?
㸢
No
㸣
Yes
Is the +5VDD line voltage normal?
㸢
No
㸣
Yes
Check each rectifying circuit of the secondary circuit and
service it if defective.
FLOW CHART NO.2
The fuse blows out.
㸣
㸣
Check the presence that the rectifying diode or
circuit is shorted in each rectifying circuit of
secondary side, and service it if defective.
㸣
㸣
After servicing, replace the fuse.
FLOW CHART NO.3
+3.3V is not outputted.
㸣
Is VCC(5V) voltage supplied to Pin(3) of IC94?
㸢
No Is M+8V voltag e supplied to Pin(2) of IC93?
㸣
Yes
㸣
Yes
Check IC34, L370, L371, C370, C371 and the periphery
circuit, and service it if defective.
Check IC93, IC94 and the periphery circuit, and service it
if defective.
FLOW CHART NO.4
The fluorescent display tube does not light up.
㸣
Is +3.3V voltage supplied to Pins(37) of FL41?
㸢
No Check the +5VDD l ine and service it if defective.
㸣
Yes
Is the voltage of approxi41V supplied to Pin(38) of
FL41?
㸢
No Check the VF line and service it if defective.
㸣
Yes
Is the voltage of approximately 3.3V supplied to Pin(1),
(43) of FL41?
㸢
No Check the FIP1/FIP2 line and service it if defective.
㸣
Yes
Check the fluorescent display tube control signal of a
microcomputer. (VFD-RST, VFD-CS, VFD-CLK, VFD-DATA
FLOW CHART NO.5
VF is not outputted.
㸣
Is approxi42V voltage supplied to the kathode of
D914?
㸢
No
Check D914, D915 and periphery circuit, and service it if
defective.
Check if there is any leak or short-circuit on the loaded
circuit, and service it if defective.
FLOW CHART NO.6
The key operation is not functioning.
Are the contact point and the installation state of the key
switches (SW41-SW47) normal?
㸢
No
Re-install the switches (SW41-SW47) correctly or replace
the poor switch.
When pressing each switches (SW41-SW47), do the voltage
of pin(86) of IC21 increase?
㸢
No
Check the switches (SW41-SW47) and their periphery, and
service it if detective.
㸣
Yes
Replace IC21.
Check if there is any leak or short-circuiting on the
primary circuit component, and service it if defective.
(T901, D902, D903, IC93, IC94)
Check t he presence t hat t he primary co mponent
㵘
is
leaking or shorted and service it if defective.
www. xiaoyu163. com
QQ 376315150
9
9
2
8
9
4
2
9
8
TEL 13942296513
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299