Figure 1-9 Mains Plate and Ground Post
3. If you need to remove the Soft Start, clip the ESD strap ground clip to the mains plate. Refer to Figure
1-9 Mains Plate and Ground Post.
4. If you only need to remove the Service Side Cover, clip the ESD strap ground clip to the cover screw
hole that is part of the compressor housing. Refer to Figure 1-10 Compressor Grounding Points on
page 25.
5. Install the top covers. Refer to Section 4.1 Compressor Covers on page 52.
Figure 1-10 Compressor Grounding Points
1.10 DC Bus Test Harness Installation and Removal
A DC bus test harness must be used when testing the voltages of the compressor’s power electronics. The DC bus
test harness is not designed to be left in the compressor during normal operation. When checks are complete,
disconnect and remove the test harness. There are two (2) different Soft Start versions referenced within these
instructions. The steps below are organized based on which Soft Start is installed on the compressor. To identify the
installed Soft Start, refer to Section 4.14 Soft Start on page 113.
M-SV-001-EN Rev. H-1/23/2023 Page 25 of 294
Summary of Contents for Turbocor TT Series
