Cylligan SY-1000S Installation And Operating Instructions Manual Download Page 1

Specifications

Pressure Range:

30–125 psi (2.1–8.62 bar)

Temperature Range:

40–100°F (4.4–37.7°C)

Rated Service Flow:

0.5 gpm (1.9 Lpm)  

Filter Capacity:

500 gallons (1893 L)

Turbidity:

5 NTU max

Parts Included:

• Filter head with built-in bracket and compression fittings
• 1000R filter cartridge
• Screws for mounting bracket
• Water supply adapter
• Lead-free drinking water faucet
• 1/4" plastic tubing

Technical Support: 1-800-645-5426

(M-F 7:30 am - 5:00 pm CST)

Precautions

WARNING:

Do not use with water that is microbiologically unsafe or of

unknown quality without adequate disinfection before or after the system.  Systems
certified for cyst reduction may be used on disinfected waters that may contain
filterable cysts.

CAUTION:

This filter must be protected from freezing, which can cause cracking

of the filter and water leakage.

CAUTION:

Because of the product’s limited service life and to prevent costly

repairs or possible water damage, we strongly recommend that the head of the
filter be replaced every ten years.  If the head of your filter has been in use for
longer than this period, it should be replaced immediately.  Date the top of any
new head to indicate the next recommended replacement date.

CAUTION:

Turn off water supply to head without cartridge if it must be left

unattended for an extended period of time.

146404 Rev D   03/04   

Easy-Change Under-Sink Drinking Water Filter System
Installation and Operating Instructions 
Model SY-1000S

• Phillips Screwdriver
• Utility Knife 

(for plastic tubing)

• Towel
• Pencil

•Tape Measure
•Adjustable Wrench
•Safety Glasses

Tools Required

•Center Punch
•1/4" and 1/2" Drill Bit

•Hand or electric drill 

(cordless recommended)

Optional Materials

NOTE: 

• For cold water use only.
• Make certain that installation complies with all state

and local laws and regulations. 

• The contaminants or other substances removed or reduced by the selected 

cartridge are not necessarily in your water. Ask your local water municipality
for a copy of their water analysis, or have your private well tested by a 
reputable water testing lab.

• After prolonged periods of non-use (such as during a vacation) it is recommended

that the system be flushed thoroughly. Let water run for 2-3 minutes before
using.

• The filter cartridge used with this system has a limited service life. Changes in

taste, odor, color; and/or flow of the water being filtered indicate that the 
cartridge should be replaced.

The SY-1000S with 750R or 1000R replacement cartridge is Tested and Certified
by NSF International to NSF/ANSI Standard 42 for the aesthetic reduction of Taste
and Odor and Chlorine and Particulate Class I*, Standard 53 for the reduction of
Cysts*, Lead*, Lindane*, Atrazine*, and Turbidity*.

*Applies to 1000R replacement cartridge only. 

Summary of Contents for SY-1000S













Reviews: