4
SAFETY INFORMATION
The Fuel System
Gas grills are used safely by millions of people when following simple safety precautions.
The items in the fuel system are designed for operation with this grill. They must not be replaced with any other
brand. (See parts list for replacement items.)
GAS BURNER:
The gas burner is constructed of stainless steel and should not require maintenance other than
inspection for insects/nests inside the air intake slots.
FUEL SUPPLY HOSE
The hose connected regulator provided with this appliance is 42 inches length. Keep the fuel hose away from any
heated surface(s).
PROPANE FUEL:
Warning - propane is a flammable gas. Improper handling may result in an explosion and/or fire
and serious accident or injury. Your grill is designed to operate with propane (LP) gas only and is equipped with the
proper orifice for propane gas.
Caution:
Do not connect this grill with any gas supply other than propane. Propane gas is heavier than air
and settles in lower areas. Make certain adequate ventilation is available when using your grill. The gas cylinder may
be stored outside in a well-ventilated area out of the reach of children when the grill is not in use. If the appliance is
not in use, the gas must be turned off at the supply cylinder.
The LP gas cylinder shall be used only outdoors in a well-ventilated space and not in a building, garage, or any
other enclosed area. The Portable Gas Grill may be stored indoor if the LP gas cylinder is removed and stored
outdoor. The LP gas cylinder (not included) is threaded for connection directly to the gas regulator supplied with
this appliance. Care should be taken when threading the cylinder to the regulator to engage threads correctly
to achieve the proper and intended connection. When disconnecting or connecting the gas cylinder, be careful
that the regulator does not strike the grill, the ground, or any other surfaces. Replace the protective cap over the
threaded cylinder connection when removed from grill. If any difficulty occurs when connecting or disconnecting
the cylinder to the regulator assembly, contact your local gas supplier for assistance.
When re-connecting the LP gas cylinder to the regulator, be sure to hand-tighten until snug. This connection
should be inspected for damage and leak tested after each re-connection.
To Leak Test,
make a soap solution of one part liquid detergent and one part water. You will need a spray bottle,
brush, or rag to apply the solution to the fitting. Bubbles indicate leaks. For more details on leak testing, refer to
page 15.
• Always operate the grill on a tabletop, no higher than 32 inches.
• Place the propane tank on the ground immediately adjacent to the grill, no less than 24 inches
from the grill.
• Failure to follow these instructions could cause the propane tank to overheat and vent propane which could
ignite causing serious personal injuries or property damage and/or a tripping hazard over the gas hose or
propane tank.
Regulator
Propane
cylinder
Check all gas supply fittings for leaks
before each use. Do not use the
grill until all connections have been
checked and do not leak.
WARNING:
