Model 30 Pavement Router Manual
Maintenance Instructions
Chapter 6
©2018 by Crafco, Inc. All Rights Reserved………………..………………………………..….…How to Use a Multimeter 6-3
6.3 Battery
Check charge condition. Keep battery connections tight and clean. Check the fluid level in battery
regularly.
Battery Recharging
6.3.1
When recharging, do not use a battery charger rated for more than 8 AMP’s. If the battery has fallen
below 10.5 volts, a charger made specifically for charging AGM batteries is required. Do not
overcharge the battery.
6.4 Periodic Maintenance
Follow a regular schedule of inspection and servicing, based on operating hours. Keep an accurate
logbook of maintenance, servicing, and operating time. Use the factory recommended Periodic
Maintenance Schedule (based on favorable operating conditions) to serve as a guide to get long
and efficient engine life.
For severe duty, extreme temperature, etc., service more frequently. Neglecting routine
maintenance can result in engine failure or permanent damage.
For any abnormalities in operation, unusual noises from the engine or accessories, loss of power,
overheating, etc., contact your nearest Kohler Service Center.
Periodically inspect the in-line fuel filter and replace when dirty using Crafco part number 31331.
WARNING
Explosive Gas!
Batteries produce explosive hydrogen gas while being charged. To prevent a fire or explosion, charge
batteries only in well ventilated areas. Keep sparks, open flames, and other sources of ignition away
from the battery at all times. Keep batteries out of the reach of children. Remove all jewelry when
servicing battery.
WARNING
Inhalation of exhaust gases can result in serious personal injury or death. DO NOT use
the air cleaner or exhaust elbow as a supporting step. Damage of these and connecting
parts might cause an exhaust leak.
WARNING
Accidental Starts!
Before servicing the engine or equipment on the machine, always disconnect the spark plug leads to
prevent the engine from starting accidentally. Ground the leads to prevent sparks that could cause
fires.
