Columbia CDVB SERIES, Installation, Operation & Maintanance Manual, Page: 16 / 28

16
IF YOU DO NOT FOLLOW THESE INSTRUCTIONS
EXACTLY, A FIRE OR EXPLOSION MAY RESULT
CAUSING PROPERTY DAMAGE, PERSONAL
INJURY OR LOSS OF LIFE.
Before operating, make certain the boiler and
system are full of water to minimum pressure
(this is usually 12 lbs. per square inch on most
systems) and system is vented of air. See the
operating and lighting instructions.
THERMOSTAT INSTALLATION
Thermostat should be installed on an inside wall about
1.
four feet above the floor.
Never install a thermostat on an outside wall.
2.
Check thermostat operation by raising and lowering ther -
3.
mostat setting as required to start and stop the burners.
Instructions for the final adjustment of the thermostat are
4.
packaged with the thermostat (adjusting heating anticipa -
tor, calibration, etc.)
THINGS TO AVOID WHEN LOCATING THERMO-
STATS
DEAD SPOTS:
Corners and alcoves Behind doors
COLD SPOTS: HOT SPOTS:
Concealed pipes or
ducts
Concealed pipes
Fireplace or chimney
Stairwells - drafts
TV sets
Radios
Unheated rooms on
other side of wall
Lamps
Direct sunlight
Outside walls
Kitchens
This appliance is equipped with an ignition device A.
which automatically lights the pilot. Do not try to light
the pilot by hand.
BEFORE OPERATING smell all around the appli
- B.
ance area for gas. Be sure to smell next to the floor
because some gas is heavier than air and will settle
on the floor.
WHAT TO DO IF YOU SMELL GAS
Do not try to light any appliance. •
Do not touch any electrical switch •
D • o not use any phone or mobile electronics in your
building.
Immediately call your gas supplier from a neighbor’s •
phone.
Follow the gas supplier’s instructions. •
If you cannot reach your gas supplier, call the fire de - •
partment.
Use only your hand to move the system control C.
switch. Never use tools. If the switch will not move
by hand, don’t try to repair it, call a qualified service
technician. Force or attempted repair may result in a
fire or explosion.
Force or attempted repair may result in a
fire or explosion.
WARNING
!
Do not use this appliance if any part has been under D.
water. Immediately call a qualified service technician
to inspect the appliance and to replace any part of the
control system and any gas control which has been
under water.
FOR YOUR SAFETY READ BEFORE OPERATING
ELECTRICAL WIRING
LIGHTING INSTRUCTIONS
CAUTION
!
WARNING
!
If these instructions are not followed exactly, a
fire or explosion may result causing property
damage, personal injury or loss of life.
WARNING
!