Page 80
CARRYALL 502 ELECTRIC
Operators Manual
TPCC01DQ00EN019 (Edition C)
WARNING
FROZEN BATTERY ACID CAN CAUSE DAMAGE INCLUDING LEAKS
AND EXPLOSIONS. IF THE BATTERY ACID FREEZES, REPLACE THE
BATTERY BEFORE CHARGING OR USE. BATTERIES IN A LOW
STATE OF CHARGE WILL FREEZE AT LOW TEMPERATURES. KEEP
THE BATTERIES IN A HIGH STATE OF CHARGE.
UNINTENDED VEHICLE OPERATION CAN CAUSE SERIOUS
PERSONAL INJURY OR DEATH. BEFORE LEAVING THE VEHICLE
OR DURING VEHICLE MAINTENANCE, DISABLE THE VEHICLE.
EXTENDED STORAGE PREPARATION
Keep sufficient water levels in each battery cell for a minimum of two weeks before extended storage
to make sure proper mixing of water and battery acid. If necessary, add water as necessary then
correctly charge batteries.
Note:
It takes approximately five charge cycles with a minimum of 10-amp hours of use after each
charge to correctly mix the water with battery acid.
To prepare your vehicle for extended storage:
1.
Turn off all electronic accessories.
2.
Set the Forward / Neutral / Reverse control (FNR) to N.
3.
Turn the key to OFF.
4.
Remove the key. Keep the key in a safe area.
5.
Put chocks against the wheels.
Note:
Do not engage the park brake.
6.
Remove all cargo and personal items.
7.
Run/Tow switch position:
7.A
On vehicles equipped with Visage that will have remote monitoring,
set the Run/Tow
switch to RUN.
7.B
On vehicles equipped with Visage that will not have remote monitoring,
set the Run/Tow
switch to TOW.
7.C
On all other vehicles,
set the Run/Tow switch to TOW.
8.
Clean the batteries.
9.
Tighten all battery cable connections to 110 lb·in (12.4 N·m).
10.
Keep the vehicle in a cool and dry area to keep battery self-discharge to a minimum.
11.
Adjust pressure in each tire to the recommended tire pressure.
Note:
Go to the approved wheel and tire assemblies matrix on
for
information regarding tire type, inflation pressure, and lugnut torque.
12.
Clean the vehicle.
Summary of Contents for CARRYALL 502 ELECTRIC
