TROUBLESHOOTING AND ELECTRICAL SYSTEM:
KEY-START WITH NEUTRAL REV GAS VEHICLE
Test Procedures
11
TEST PROCEDURES
Index of Test Procedures
1 – Battery
2 – Fuse
3 – Ground Cables
4 – Key Switch (Starter Circuit)
5 – Key Switch (Accessory Terminal)
6 – Solenoid
7 – Neutral Lockout Limit Switch
8 – Starter/Generator (Starter Function)
9 – Wire Continuity
10 – Diode (Generator Circuit)
11 – Starter/Generator (Generator Function)
12 – Voltage Regulator
13 – Grounded Kill Wire
14 – Ignition Spark
15 – RPM Limiter
16 – Ignition Coil
17 – Key Switch (Engine Kill Circuit)
18 – Engine Kill Wire
19 – Reverse Buzzer Limit Switch
20 – Reverse Buzzer
21 – Oil Level Sensor
22 – Oil Warning Light
23 – Battery Test (Under Load)
24 – Fuel Level Sending Unit
25 – Fuel Gauge
26 – Hour Meter
27 – Light Switch
28 – Headlight Diode
29 – Voltage at Headlight Socket
TEST PROCEDURE 1 – Battery
See General Warning on page 1-1.
DANGER
• Due to the danger of an exploding battery, wear a full face shield and rubber gloves when working
around a battery.
• Battery – Explosive gases! Do not smoke. Keep sparks and flames away from the vehicle and
service area. Ventilate when charging or using in an enclosed space. Wear a full face shield and
rubber gloves when working on or near batteries. For added protection, cover top of the battery
when servicing the vehicle.
• Battery – Poison! Contains acid! Causes severe burns! Avoid contact with skin, eyes, or clothing.
– External: Flush with water. Call a physician immediately.
DANGER CONTINUED ON NEXT PAGE
2007-2009 Turf 252, Carryall 252 and XRT 900 Maintenance and Service Manual
Page 11-9
