Club Car Carryall 1 2007, Owner'S Manual

Page: 58 / 80

Fueling Instructions – Gasoline Vehicle
Page 56 2007 Turf/Carryall Vehicle Owner’s Manual
13. Remove the dipstick and add engine oil into the dipstick port. Use a funnel or pour spout to direct the oil
into the dipstick port. With filter change, the engine requires 38 ounces (1.12 liters) of oil per change.
Refer to oil viscosity guidelines for selection of oil grade (Figure 32) . Replace the dipstick.
14. Connect the battery cables, positive (+) cable first, and tighten terminals to 12 ft-lb (16 N·m). Coat ter-
minals with Battery Terminal Protector Spray (CCI P/N 1014305).
15. With the Forward/Reverse handle in the NEUTRAL position, start and run the engine for a few minutes.
Observe both the drain plug and the oil filter from under the vehicle and watch for oil leaks. If leaks
appear, begin with step 1 and repeat the appropriate step for either or both items to correct the problem.
16. Remove the dip stick and check the engine oil as a final step. Replace the dip stick.
FUELING INSTRUCTIONS – GASOLINE VEHICLE
See General Warnings on page 17.
ý
DANGER
• Turn the key switch to the OFF position before fueling.
• Do not pour gasoline into the fuel tank when the engine is hot or while it is running.
• To avoid electric arc caused by static electricity, the fuel storage/pumping device must be
grounded. If the pump is not grounded, the vehicle must be grounded to the pump before and
during the fueling operation.
• If the vehicle has an all-weather enclosure installed, be sure the fuel tank is properly vented as
shown (Figure 33).
• To avoid the possibility of fire, clean up any spilled gasoline before operating the vehicle.
ý
CAUT ION
• To allow for expansion, do not fill higher than one inch from top of the fuel tank. Avoid spilling fuel.
NOTE: Whenever possible, avoid using oxygenated fuels and fuels that are blended with alcohol. Vehicles
to be stored for extended periods should be prepared for storage as instructed. See Preparing the
Gasoline Vehicle for Extended Storage on page 39.
Figure 31 Coat Oil Filter Rubber Seal Figure 32 Oil Viscosity Chart
°
°
° ° ° ° ° °
C
° ° ° °
°
°
°
-20 C -10 C 0 C
10 C
20 C
-4 F F 32 F
68 F
86 F 104 F
SAE 5W-20
SAE 10W-30/SAE 10W-40
SAE 30
SAE 40
30 40
14
50 F