Club Car 2006 DS Golf, Owner'S Manual

Page: 27 / 44

Periodic Service Schedule
2006 Gold Standard Electric Vehicle Owner’s Manual Page 23
ý
WARNING
• If any problems are found during scheduled inspection or service, do not operate the vehicle
until repairs are made. Failure to make necessary repairs could result in fire, property
damage, severe personal injury, or death.
PERIODIC SERVICE SCHEDULE
REGULAR INTERVAL SERVICE
Daily service by owner Batteries Charge batteries (after each use only).
Weekly service by owner Batteries
Check electrolyte level. Add water if
necessary.
See page 27.
Monthly service by owner
or trained technician
Batteries
Wash battery tops and clean terminals
with baking soda/water solution.
Tires
Check air pressure and adjust if
necessary.
Wiper switch
See Figure 12, Page 25 to determine
applicability .
Check for cracks or other damage; make
sure switch is securely fastened to frame.
Check moveable contact for correct
operation.
General vehicle
Wash battery compartment and underside
of vehicle.
Semiannual service by trained
technician only
(every 50 hours of operation
or 100 rounds of golf)
Brake system
Check brake shoes; replace if necessary.
See Section 6 – Wheel Brake
Assemblies in the appropriate
maintenance and service manual.
Lubricate brake slides per Lubrication
Schedule.
See Section 6 – Wheel Brake
Assemblies in the appropriate
maintenance and service manual.
Check brake cables for damage; replace if
necessary.
Electrical wiring and connections Check for tightness and damage.
Forward/Reverse switch
Check condition of contacts and wire
connections. Make sure connections are
tight.
Front wheel alignment and camber
Check and adjust as required. See
Section 7 – Steering and Front
Suspension in the appropriate
maintenance and service manual.
Motor controller output regulator (MCOR)
See Figure 13, Page 25 to determine
applicability .
Check for loose hardware, cracks and
other damage.
Annual service by
trained technician only
(every 100 hours of operation
or 200 rounds of golf)
Batteries
If batteries are not performing as
expected, see Section 13 – Batteries in
the appropriate maintenance and service
supplement.