Clemas & Co DEMON TYPHOON 2, Operator'S Manual

Page: 8 / 38

Demon Typhoon Manual Issue 1/07
Page 7
DAILY CHECK THE FOLLOWING
a. Oil level ‐ top up as required.
b. Fuel tank ‐ top up as required.
c. All hose unions for leaks.
d. Hose condition ‐ cuts etc.
Engine Service ‐ Refer to Yanmar or Isuzu service intervals in manual supplied with Typhoon.
EVERY 500 HOURS OR SIX MONTHS (WHICHEVER COMES FIRST)
a. Drain and replace pump oil. MINIMUM SERVICE SCHEDULES
b. Drain and refill fuel tank.
c. Clean and reset electrodes.
d. Replace fuel filter.
e. Clean water filter.
f. Replace high pressure nozzle.
g. Replace fuel nozzle.
h. Descale water system. (hard water areas only)
i. Note: in extreme hard water areas it may be necessary to fit a limefighter device which is a
ceramic magnetic tube that ionises the calcium carbonate allowing them to pass through
the pressure washer and not form deposits inside.
EVERY 1000 HOURS OR 12 MONTHS (WHICHEVER COMES FIRST)
a. Complete 500 hour service.
b. Replace pump seals.
c. Replace oil seals.
d. Check float level.
e. Replace chemical pipes.
f. Check unloading pressure and safety valve pressure and adjust.
g. Replace fuel nozzle and set fuel pressure.
h. Check flow switch and adjust if necessary.
i. Check electrical connections for tightness.
The above service schedules are intended as a guide only, actual service times and
replacements parts required will vary according to the area and the usage of the
machine.
MINIMUM SERVICE SCHEDULES