Char-Broil 18202077, Product Manual

Page: 2 / 32

2
TABLE OF CONTENTS
INSTALLER/ASSEMBLER:
Leave this manual with consumer.
CONSUMER:
Keep this manual for future reference.
This instruction manual contains important information
necessary for the safe use of the appliance.
Follow all warnings and instructions when using the
appliance.
Safety Symbols
The symbols and boxes shown below explain what each heading
means. Read and follow all of the messages found throughout
the manual.
DANGER
WARNING
CAUTION
CAUTION
DANGER: Indicates an imminently hazardous situation
which, if not avoided, will result in death or serious injury.
WARNING: Indicates an potentially hazardous situation
which, if not avoided, could result in death or serious
injury.
CAUTION: Indicates a potentially hazardous situation or
unsafe practice which, if not avoided, may result in minor
or moderate injury.
For residential use only. Do not use for commercial
cooking.
IMPORTANT SAFEGUARDS
When using electrical appliances, basic safety
precautions should always be followed including the
following:
READ ALL INSTRUCTIONS
Ÿ
Do not touch hot surfaces. Use handles or knobs.
Ÿ
To protect against electrical shock, do not immerse cord,
plugs, controller or heating element in water or any other
liquid.
Ÿ
Close supervision is necessary when any appliance is used
by or near children.
Ÿ
Unplug from outlet when not in use and before cleaning.
Allow to cool before putting on or taking off parts.
Ÿ
Do not operate any appliance with a damaged cord or plug
or after the appliance malfunctions or has been damaged in
any manner.
Ÿ
The use of accessory attachments not recommended by the
appliance manufacturer may cause injuries.
Ÿ
Do not let cord hang over edge of table or counter, or touch
hot surfaces.
Ÿ
Do not place on or near a hot gas or electric burner, or in a
heated oven.
Ÿ
Extreme caution must be used when moving an appliance
containing hot oil or other hot liquids.
Ÿ
Do not use appliance for other than intended use.
Ÿ
Use only with GFI (Ground Fault Interrupter) protected
circuit.
Ÿ
To prevent smoker from being splashed or falling into water,
do not use smoker within 10 feet of a pool, pond or other
body of water.
Ÿ
Keep smoker and electric controller dry and out of rain at all
times.
Ÿ
When connecting controller to smoker, plug electric controller
into smoker first, make sure controller is set to OFF position,
then plug into outlet. When unplugging, turn controller to
OFF position, disconnect from outlet, then remove controller
from smoker.
Ÿ
Unplug smoker when not in use and before moving.
Ÿ
Never remove grounding plug or use with an adapter to two
prongs.
Ÿ
Keep electric plugs off ground and dry.
Ÿ
Store controller indoors when not in use.
Ÿ
Do not use water or other liquid spray to clean product
without first unplugging electric controller and removing
heating element
.
Ÿ
Fuel, such as charcoal briquettes, is not to be used with
appliance.
Ÿ
Use only on properly grounded outlet.
SAVE THESE INSTRUCTIONS
Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . .1
Safety Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . 2-5
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . 6
Parts List .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Parts Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Hardware List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . .. . . . . . . . 21
Assembly . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22-25
Troubleshooting . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Registration Card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31