Art. No.
99BB004
e
Gas grill MASTER CHEEF
-4-
USE ONLY HOSES AND HOSE COUPLINGS
SUPPLIED BY THE MANUFACTURER
If a replacement is necessary, contact your
local dealer.
The use of unauthorised parts can create
unsafe conditions and environment!
FOR USE OUTDOORS AND IN WELL VENTILATED
AREAS
WARNING: ACCESSIBLE PARTS MAY BE VERY HOT,
KEEP YOUNG CHILDREN AWAY
READ THE INSTRUCTION LITERATURE BEFORE
USING THE APPLIANCE
Ignition:
Main Burner:
Single shot piezo ignition unit which lights a transient
pilot
Side Burner:
Single shot piezo ignition unit
IMPORTANT:
Read the following instructions carefully and be sure your barbecue is
properly installed, assembled and cared for. Failure to follow these
instructions may result in serious bodily injury and/or property
damage.
If you have any questions concerning assembly or operation, consult
your dealer or LPG Gas Company.
When used on the ground always place the appliance and cylinder on
flat level ground.
Never light the appliance with the HOOD in the closed position.
Your barbecue can be used on gas cylinders between 11 kg and 15
kg. Your barbecue will perform better if propane or LPG mixtures are
used. Butane can be used but because of the rate of the appliance
the cylinder will tend to freeze and supply gas at reduced pressures
affecting the performance of your barbecue.
When siting the barbecue the following clearances must be obeyed:
Sides and rear of appliance: 1 metre from any obstruction.
Above the appliance: NO OVERHEAD OBSTRUCTION ARE
PERMITTED.
NOTE FOR CONSUMER: Retain for future Reference
CONNECTING THE GAS CYLINDER TO THE APPLIANCE
This appliance is only suitable for use with low-pressure butane or
propane gas or LPG mixtures, fitted with the appropriate low-
pressure regulator via a flexible hose. The hose should be secured to
the regulator and the appliance with hose clips. This barbecue is set
to operate a 28 mbar regulator with butane gas and a 37 mbar regula-
tor with propane gas 30 mbar for LPG mixtures, or 37 mbar for LPG
mixtures, or 50 mbar for LPG mixtures. Use a suitable regulator certi-
fied to BSEN 12864: 2001. Please consult your LPG dealer for infor-
mation regarding a suitable regulator for the gas cylinder.
Regulator and Hose
This item is supplied with the barbecue, but replacements are availa-
ble from your equipment retailer or an authorised LPG gas stockist.
Use only regulators and hose approved for LP Gas at the above pres-
sures. The life expectancy of the regulator is estimated as 10 years.
It is recommended that it the regulator is changed within 10 years of
the date of manufacture.
The use of the wrong regulator or hose is unsafe; always check that
you have the correct items before operating the barbecue.
The hose used must conform to the relevant standard for the country
of use. The length of the hose must be 1.5 metres (maximum). Worn
or damaged hose must be replaced. Ensure that the hose is not
obstructed, kinked, or in contact with any part of the barbecue other
than at its connection.
Storage of Appliance
Storage of an appliance indoors is only permissible if the cylinder is
disconnected and removed from the appliance. When the appliance
is not to be used for a period of time it should be stored in its original
packaging and stored in a dry dust free environment.
Gas Cylinder
The gas cylinder should not be dropped or handled roughly! If the
appliance is not in use, the cylinder must be disconnected. Replace
the protective cap on the cylinder after disconnecting the cylinder
from the appliance.
Cylinders must be stored outdoors in an upright position and out of
the reach of children. The cylinder must never be stored where tem-
peratures can reach over 50°C. Do not store the cylinder near flame-
s, pilot lights or other sources of ignition. DO NOT SMOKE.
This barbecue is designed for use outdoors, away from any flamma-
ble materials.
It is important that there are no overhead obstructi-
ons
and that there is a minimum distance of 1 m from the side or rear
of the appliance. It is important that the ventilation openings of the
appliance are not obstructed. The barbecue must be used on a level,
stable surface. The appliance should be protected from direct
draughts and shall be positioned or protected against direct pene-
tration by any trickling water (e.g. rain).
Parts sealed by the manufacturer or his agent must not be alte-
red by the user. No modifications should be made to any part of
this barbecue and repairs and maintenance should only be
carried out by a CORGI registered service engineer.
Connection to Appliance
Before connection, ensure that there is no debris caught in the head
of the gas cylinder, regulator, burner and burner ports. Spiders and
insects can nest within and clog the burner/venturi tube at the orifice.
A clogged burner can lead to a fire beneath the appliance.
Clean burner holes with a heavy-duty pipe cleaner.
INSTRUCTION MANUAL
Summary of Contents for 99BB004
