4
To re-install the access panel:
1. Slide the top of the panel up under the unit top panel.
2. Slide the bottom into the side channels.
3. Push the bottom flange down until it contacts the top of
the lower panel (or economizer top).
Outside Air Hood
Outside air hood inlet screens are permanent aluminum-mesh type
filters. Check these for cleanliness. Remove the screens when
cleaning is required. Clean by washing with hot low-pressure wa-
ter and soft detergent and replace all screens before restarting the
unit. Observe the flow direction arrows on the side of each filter
frame.
Economizer Inlet Air Screen
This air screen is retained by filter clips under the top edge of the
hood. (See Fig. 3.)
Fig. 3 — Filter Installation
To remove the filter, open the filter clips. Re-install the filter by
placing the frame in its track, then closing the filter clips.
Manual Outside Air Hood Screen
This inlet screen is secured by a retainer angle across the top edge
of the hood. (See Fig. 4.)
Fig. 4 — Screens Installed on Outdoor-Air Hood
(Sizes 7
1
/
2
to 8
1
/
2
Tons Shown)
To remove the screen, loosen the screws in the top retainer and slip
the retainer up until the filter can be removed. Re-install by plac-
ing the frame in its track, rotating the retainer back down, and
tightening all screws.
SUPPLY FAN (BLOWER) SECTION
Supply Fan (Direct-Drive)
For unit sizes 04, 05, and 06, a direct-drive forward-curved cen-
trifugal blower wheel is an available option. The motor has taps to
provide the servicer with the selection of one of five motor torque/
speed ranges to best match wheel performance with attached duct
system. See Fig. 5 and 6.
Fig. 5 — Direct-Drive Supply Fan Assembly
Fig. 6 — ECM Motor Connectors
ECM MOTOR
The direct-drive motor is an X13 Electronically Commutated Mo-
tor (ECM). An ECM motor contains electronic circuitry used to
convert single-phase line AC voltage into 3-phase DC voltage to
power the motor circuit. The motor circuit is a DC brushless de-
sign with a permanent magnet rotor. On the X13 ECM Motor
17 1/4”
DIVIDER
BAROMETRIC
RELIEF
CLEANABLE
ALUMINUM
FILTER
FILTER
HOOD
FILTER
CLIP
OUT
S
IDE
AIR
SCREWS
WARNING
ELECTRICAL OPERATION HAZARD
Failure to follow this warning could result in personal injury or
death.
Before performing service or maintenance operations on unit,
LOCKOUT/TAGOUT the main power switch to unit. Electri-
cal shock and rotating equipment could cause severe injury.
ECM Motor
Motor Plug Position
(95° from vertical)
95°
ECM Power
Transformer
(460, 575v)
L2
YEL
Gnd
GRN/YEL
L1
BLU
C
1 2 3 4 5
L G N
Motor
Power
Connections
Speed
Taps
Com
BRN
VIO
Default Connection
Summary of Contents for WeatherMaster 48HC04 Series
