ii
TABLE OF CONTENTS (CONT’D)
Section
Page
4
SERVICE (CONT’D)
4-1
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4.17 Removing the Condenser Fan Motor
4-10
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4.18 Servicing the Evaporator Fan Blower Motor Assembly
4-11
. . . . . . . . . . . . . . . . . . . . . . . . .
4.19 Replacing the Return Air Filters
4-11
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4.20 Compressor
4-11
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4.20.1 Replacing the Compressor
4-11
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4.20.2 Checking the Compressor Oil Level
4-12
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4.20.3 Adding Oil to the Installed Compressor
4-12
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4.20.4 Adding Oil to Service Replacement Compressor
4-13
. . . . . . . . . . . . . . . . . . . . . . .
5
ELECTRICAL
5.1
Introduction
5-1
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
LIST OF ILLUSTRATIONS
Figure
Page
1-1
Evaporator Assembly - Top View
1-2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1-2
Condenser Assembly - Top View
1-3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1-3
Electrical Control Panel Components for Models with Rotron Brushless Motors
1-4
. .
1-4
Reheat Coolant Valve
1-9
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1-5
Heater Coolant Flow Diagram
1-9
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1-6
Refrigeration Cycle Diagram
1-10
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2-1
Temperature Controller Sequence During Cooling Mode
2-2
. . . . . . . . . . . . . . . . . . . . .
2-2
Temperature Controller Sequence During Cooling with Reheat Mode
2-2
. . . . . . . . . .
2-3
Temperature Controller Sequence During Heating Mode
2-3
. . . . . . . . . . . . . . . . . . . . .
2-4
Cooling Cycle - High Speed Vent Mode Operation
2-4
. . . . . . . . . . . . . . . . . . . . . . . . . .
2-5
High Speed Unloaded (2-cylinder operation) Cool Mode Operation
2-5
. . . . . . . . . . . .
2-6
High Speed Semi-loaded (4-cylinder operation) Cool Mode Operation
2-6
. . . . . . . . .
2-7
High Speed Fully Loaded (6-cylinder operation) Cool Mode Operation
2-7
. . . . . . . . .
2-8
High Speed Unloaded (2-cylinder operation) Cool with Reheat Mode Operation
2-8
.
2-9
Heating Cycle - Low Speed Heat Mode Operation
2-9
. . . . . . . . . . . . . . . . . . . . . . . . . . .
4-1
Suction or Discharge Service Valve
4-1
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-2
Gauge Manifold Set
4-2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-3
Evacuation Manifold
4-4
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-4
Evacuation Set-Up
4-5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-5
Filter Drier Removal
4-6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-6
Checking High Pressure Switch
4-6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-7
Thermostatic Expansion Valve
4-7
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-8
Thermostatic Expansion Valve Bulb and Thermocouple
4-8
. . . . . . . . . . . . . . . . . . . . . .
4-9
Reheat Coolant Valve Assembly
4-9
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-10
Liquid Line Solenoid Valve - Alco
4-10
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-11
Compressor Oil Charge Connections
4-13
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-12
Compressor - Model O5G
4-13
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5-1
Electrical Wiring Schematic Diagram (68RF50 with Rotron Brushless Motors),
Dwg. No. C-070-935, Rev C
5-2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .