CareFusion Alaris 8110 series, Service Manual

Page: 122 / 172

€
Replacement of the Complete Housing Assembly, Force Sensor Assembly or Logic Board Assembly in a
Syringe Module with version
7
or earlier software must be performed at the depot. Refer to the note in
section
7.4
for further information.

• The Top disk Holder, Internal Frame, Shaft Support and various Syringe Barrel Clamp Assembly parts
identified here are not backwards compatible with a Syringe Barrel Clamp Assembly having a Park
Position “Pin” attached. Prior to ordering any of these parts, reference the “Corrective Maintenance”
chapter for part identification and replacement instructions.
• Newer versions of the Park Position Collar and Barrel Clamp are not interchangeable with earlier
versions. If either part requires replacement and the hex head bit,
1
/
16
HX
,
1
15
/
16
” length tool was used to
remove the Park Position Collar
0.062
” setscrew, both parts must be replaced.
‚
Order the Front Case “Kit” when replacing an “old version” Front Case, Syringe Barrel Clamp Assembly (or
associated part), or Top Disk Holder (reference Figure
7A-7
).
ƒ
Order the Front Case “Assembly” when replacing a “new version” Front Case, Syringe Barrel Clamp Assembly
(or associated part), or Top Disk Holder (reference Figure
7A-7
).
„
The Base Disk Holder can be relaced as an individual part only if it is used with a “new version” Front Case. If
an “old version” Front Case is in use, order item 9, Front Case “Kit” (reference Figure
7A-7
).
Not sold by Car efusion .
CAUTIONS
ILLUSTRATED PARTS BREAKDOWN
Syringe Module
7A-6
Alaris
®
Syringe Module (8110 Series)
Alaris
®
PCA Module (8120 Series)
Technical Service Manual
Table 7A-1. Parts List - Syringe Module
(Continued)
Item Part Number Description QTY
496
499
645
646
2003
2004
2006
321035
148013-000
125569
147077-100
147078-100
147080-100
10010720
10010199
10012555
10012398
148089-001
Screw, 4-40 x
3
/
4
, PNH PHH
Silicone Grease, Dow Corning Molykote 33, or equivalent (use with
item
410
)
Label, Patent
Label, Serial Number Replacement
IUI Connector Kit, Right
(Includes: Right Gasket, Right
IUI
Connector)
IUI Connector Kit, Left
(Includes: Left Seal, Left
IUI
Connector)
Latch Kit
(Includes: Latch, Compression Spring, Leaf Spring, Support)
Directions for Use:
PCA Module (V7)
Syringe Module (V7)
Alaris
®
System (supports Guardrails
®
Suite MX):
Electronic Copy
Printed Copy
Set Compatibility Card
6
As required
1
1
1
1
1
1
1