Carefree FREEDOM FREESTYLE WM, Service Manual

Page: 21 / 24

Carefree of Colorado Service Manual F
REEDOM
F
REESTYLE
WM
052573-301r8 17
S
TANDARD
M
AINTENANCE
Maintaining a Carefree Awning is easy. Just follow these basic steps:

Always operate the awning according to the instructions.

Periodically check that the fasteners are tight. Tighten if necessary.

Keep the awning fabric and arms clean.
F
ABRIC
C
ARE
NOTICE
Do not use oil based cleaners or any caustic, granulated, or abrasive type cleaners
on your Carefree product.
1. One of the best ways to keep the fabric looking good and to delay the need for deep or vigorous
cleanings is to hose fabrics off on a monthly basis with clear water. This practice will help prevent dirt
from becoming deeply imbedded in the fabric. In most environments, a thorough cleaning will be
needed every two to three years.
2. When it is time for a thorough cleaning, the fabric can be cleaned while still on the awning frame.

For Vinyl Fabric – Use a soft brush and warm water with soap.

For Acrylic Fabric – Use a stiff brush and warm water with soap.
3. When cleaning the fabric, it is important to observe the following:

Always use a natural soap, never detergent.

Water should be cold to lukewarm, never more than 100

F.

Air-dry only. Never apply heat to the fabric.

Always allow the fabric to dry thoroughly before rolling up the awning.
Mildew
Mildew is a fungus growth that looks like dirt. Vinyl coated polyester fabrics are mildew resistant because of a
chemical biocide in the vinyl coating. Under ordinary conditions, mildew will not appear. However, in areas where
high temperature and humidity are common, mildew can be a problem and require the material to be washed
more frequently.
Pooling
When water collects on the top of the fabric, this is known as "pooling". This can occur during inclement weather
or if a running air conditioner discharges over the awning. The water is dumped when the awning is retracted. It is
recommended that if water accumulates; retract the awning in steps (8"-12") to dump the water. This will help
prevent the fabric from stretching or distorting.
Leaking
On vinyl canopies, side hems and poly cords are stitched in with a sewing machine. On occasion, this
stitching may allow water to seep or leak through the stitches. This is normal and not a defect covered by
warranty. Treat the seams with a quality seam sealer.
M
OTOR
M
AINTENANCE

Check all wiring and connections for wear. Repair when needed.

Check that the sealant is providing a good seal and no water is accumulating on the wiring.