OPERATION
RMB 1865 11/10
Operation Section 4-45
© 2010 Alamo Group Inc.
OPERA
T
ION
TROUBLE
POSSIBLE CAUSE
POSSIBLE REMEDY
Excessive Vibrations
Blade Broken.
Replace blades, in sets.
Blade carrier bent.
Replace carrier.
Blade hub not properly
Remove hub, check tapered spline
seated on shaft
shaft, clean and replace.
New Blade or bolts matched
Replace blades or bolts in sets
Drivelines not phased correctly.
Replace Drivelines.
Implement & tractor yokes must
be in line.
Gearbox Overheating
Low on lubricant.
Fill to level plug.
Improper type lubricant.
Replace with NLGI 000 lubricant.
Excessive trash build-up
Remove trash.
around gear box
Bearing or gears set up improperly
Consult your dealer.
Gearbox Noisy
Rough Gears.
Run in or change gears.
Worn Bearing.
Replace bearing.
Noise
Damaged Belt Shield
Straighten or replace Shields.
(Rubbing on pulleys or belt).
Worn Bearing or Gear.
Replace Bearing or Gear.
Gearbox Leaking
Damaged oil seal
Replace seal.
Bent shaft.
Replace oil seal and shaft.
Shaft rough in oil seal area.
Replace or repair shaft.
Oil seal installed wrong.
Replace seal.
Oil seal not sealing
Replace seal or use a sealant on
in the housing.
OD of Seal.
Oil level too high.
Drain oil to proper level.
Sand hole is casting.
Replace castings or gearbox.
Gasket damaged.
Replace gasket.
Bolts loose.
Tighten bolts.
Summary of Contents for RMB 1865
