BorMann BSC6000, Operator'S Manual, Page: 8 / 13

www.BormannTools.com
BATTERY CHARGER
OPERATOR'S MANUAL
IMPORTANT SAFETY INSTRUCTIONS
1. SAVE THESE INSTRUCTIONS. This manual contains important safety and operating
instructions. You may need to refer to these instructions at a later date.
2. CAUTION.
To reduce risk of injury, charge only wet cell, lead - acid, automotive
type rechargeable batteries. Other types of batteries may burst causing personal
injury and property damage.
3. Do not expose charger to rain or snow.
4. Use of an attachment not recommended or sold by the battery charger
manufacturer may result in a risk of fire, electric shock, or injury to persons.
5.
To reduce risk of damage to electric plug and cord, pull by plug rather than cord
when disconnecting charger.
6. Make sure cord is located so that it will not be stepped on, tripped over, or
otherwise subjected to damage or stress.
7. An extension cord should not be used unless absolutely necessary. Use of
improper extension cord could result in a risk of fire and electric shock. If an
extension cord must be used, make sure:
a. That pins on plug of extension cord are the same number, size, and shape as those
of plug on charger;
b. T hat extension cord is properly wired and in good electrical condition; and
c. If the length of the extension cord is less than 25 feet, use an 18AWG cord, If 50
feet - 18AWG, 100 feet - 16AWG, 150 feet - 14AWG.
8. Do not operate charger with damaged cord or plug, replace the cord or plug
immediately.
9. Do not operate charger if it has received a sharp blow, been dropped, or
otherwise damaged in any way; take it to a qualified serviceman.
10. Do not disassemble charger; take it to a qualified serviceman when service or
repair is required. Incorrect reassembly may result in a risk of electric shock or fire.
11. To reduce risk of electric shock, unplug charger form outlet before attempting
any maintenance or cleaning. Turning off controls will not reduce this risk.
12. WARNING - RISK OF EXPLOSIVE GASES a. WORKING IN VICINITY OF A LEAD -
ACID BATTERY IS DANGEROUS. BATTERIES GENERATE EXPLOSIVE GASES DURING
NORMAL BATTERY OPERATION. FOR THIS REASON IT IS OF UTMOST IMPORTANCE
THAT EACH TIME BEFORE USING YOUR
CHARGER, YOU READ THIS MANUAL AND FOLLOW THE INSTRUCTIONS EXACTLY.
b. To reduce risk of battery explosion, follow these instructions and those published
by battery manufacturer and manufacturer of any equipment you intend to use in
vicinity of battery. Review cautionary marking on these products and on engine.
13. PERSONAL PRECAUTIONS
a.
Someone should be within range of your voice or close enough to come to your
aid when you work near a lead - acid battery.
b. Have plenty of fresh water and soap nearby in case battery acid contacts skin,
clothing, or eyes.
c. Wear complete eye protection, and clothing protection. Avoid touching eyes while
working near battery.
d. If battery acid contacts skin or clothing, wash immediately with soap and water. If
acid enter eye, immediately flood eye with running cold water for at least 10
minutes and get medical attention immediately.