4
Build-in Barbeques
Island Barbeques
Barbeques Galore have available a stone-topped pre-built island complete with optional table and sink/fridge modules
.
These modules are designed specifically for your Ziegler & Brown Turbo barbeque, with all required clearances for
aeration and hood
opening observed. The barbeque module has a dedicated stand for a portable gas cylinder, or
run a gas pipe or hose in the gap underneath the island for permanent gas connections.
All other details in these instructions apply equally well to barbeques in these island modules.
It is possible to install the Ziegler & Brown Turbo barbeque into a dedicated enclosure, provided that a few
requirements are met:
s
Adequate clearance around the barbeque must be provided. This ensures that the burners have a supply of fres
h
air to operate correctly. Failure to provide enough fresh air to the burners can cause the production of dangerous
noxious gases.
s
Adequate distance from combustible materials - The required clearances from combustible materials are listed o
n
the data plate on your barbeque. The enclosure itself must be made of non-combustible material.
s
Sufficient space behind the barbeque for the roasting hood to open freely.
In addition, where the cylinder is kept in an enclosed space underneath or near the barbeque, the following must b
e
observed:
s
The cylinder must rest on a base to ensure that water will not accumulate, and that the cylinder is clear of the
surrounding soil.
s
There must be at least 200cm
2
of ventilation openings per cylinder stored, at both the top and bottom of the
cylinder compartment, so that any accumulating gas can quickly escape to the outside air. The lower ventilation
should be as close as possible to the ground.
The diagram below shows the recommended cutout dimensions for both the barbeque and the side burner.
Brackets to hold the barbeque and side burner into a dedicated cavity are supplied with the appliance when you
purchase it as a build in.
40m
m
13
5m
m
514m
m
514m
m
Width
410mm
276mm
50mm
Barbeque Width:
2 burner
574 mm
4 burner
844 mm
Sample enclosure showing critical dimensions. Enclosure
must be made of non-combustible materials.
alternatively, you can
