Ultimate Ozone™ Installation and User’s Guide
Rev: 030717
PLEASE READ, FOLLOW, AND SAVE THESE INSTRUCTIONS!
Attention Installer:
Read this manual completely before attempting installation. Failure to follow these
instructions could result in injury or death and will void the product warranty. Consult AquaStar Pool
Products with any question regarding this product. This guide must be left with the pool owner.
Attention User:
This guide contains important information about the installation, operation and safe use
of this product. Please retain this guide for future reference.
FAILURE TO FOLLOW ALL INSTRUCTIONS AND WARNINGS CAN RESULT IN SERIOUS
BODILY INJURY OR DEATH.
THIS OZONE SYSTEM SHOULD BE INSTALLED AND SERVICED ONLY BY A
QUALIFIED POOL PROFESSIONAL.
DO NOT INHALE OZONE GAS PRODUCED BY THIS PRODUCT
. Short-term inhalation
of high concentrations of ozone and long-term inhalation of low concentrations of ozone can cause
serious harmful physiological effects. The ozone system box and ozone stone must be installed in outdoor
locations only, or indoor locations with forced air ventilated rooms and indoor pool and spas areas must
be ventilated in accordance with ASHRAE Standard 62.1 2013, Ventilation for Acceptable Indoor Air
Quality, and/or applicable local codes.
IMPORTANT SAFETY INSTRUCTION! PLEASE READ PRIOR TO
INSTALLATION AND OPERATION!
The installation, operation and servicing of this ozone system can only be carried out
after reading and understanding the information contained in this guide. The installation must be
performed in accordance with all federal, state and local regulations and codes.
This product must be wired in conjunction with a properly grounded, Ground Fault
Circuit Interrupter (GFCI).
Only three (3) wire grounded cord suitable for outdoor use should be used to
connect this product. For outdoor use, a suitable watertight cord connector must be used. If an extension
cord is necessary, a cord with a proper outdoor rating must be used. Locate the cord so that it will not be
tripped over or pulled. If in doubt consult a qualified electrician.
Receptacles that provide power for this product must be located at least 10 feet
(3.0 meters) from the inside wall of the pool or spa. The ozone unit box must be installed at least 5 feet
(1.5 meters) from the inside wall of the pool or spa and no less than one foot above overflow water level to
prevent water from contacting electrical equipment.
ELECTRIC SHOCK HAZARD! Disconnect from power source before opening the ozone
system box for any reason. Failure to do so can result in serious injury or death.
Never attempt any servicing while unit is wet. Do not store or use gasoline, chemicals
or other flammable liquids or vapors near this or any other appliance. Do not permit children to use this
product.
ONLY use ozone compatible tubing and ozone stone. Never replace with metal tubing.
1