Applied L-25 Instructions Manual Download Page 7

Page: 7 / 10

Applied

Truss and Electronics

Rope over head block.

STEP#4

ATTACH CABLE &

RAISE TOWER

L-25 MINI TOWER

INSTRUCTIONS

A) Unwrap the cable and feed it around the head block (remove and replace retaining

pins above the pulleys) and connect to the slide block aligning the thimble between the

angles and inserting the clevis pin.

B) If towers are outside, now is a good time to attach the guy wires. Refer to the

engineering document for number and locations of guy wires.

C) We suggest attaching a rope over the top of the tower, down

the other side and secured at a location you can reach from the

ground. Have 1 person pull the rope while 2 people walk up the

tower to vertical. Disconnect the rope once the tower is secure.

PROUDLY MADE IN THE U.S.A.

722 Blue Crab Road

Newport News, VA 23606

757.591.9371 / fax 757.591.9514

www.appliednn.com

REVISED: 10/24/2017

Summary of Contents for L-25

Page 1: ...s and Electronics 1 L 25 MINI TOWER INSTRUCTIONS ATTENTION 1200 lb WEIGHT LIMIT PROUDLY MADE IN THE U S A 722 Blue Crab Road Newport News VA 23606 757 591 9371 fax 757 591 9514 www appliednn com REVISED 10 24 2017 ...

Page 4: ...washers and 1 nut for each B Assemble a leg brace to each of the legs using a 3 8 16 x 3 1 2 grade 5 bolt and 2 flat washers and 1 nut for each Attach 3 of the braces as shown using the t pins and leave the brace out on the slide plate side PROUDLY MADE IN THE U S A 722 Blue Crab Road Newport News VA 23606 757 591 9371 fax 757 591 9514 www appliednn com REVISED 10 24 2017 ...

Page 5: ...de 5 bolts using 1 flat washer and 1 nut for each B Wind the cable onto the winch paying close attention that the cable does not cross itself C Remove bolts and pivot hinge to attach tower sections PROUDLY MADE IN THE U S A 722 Blue Crab Road Newport News VA 23606 757 591 9371 fax 757 591 9514 www appliednn com REVISED 10 24 2017 ...

Page 10: ... is at the required height the safety bar should be set on each tower This is accomplished by using the ladder side of the tower to reach the trim height of the system and tighten the bar as shown Locate to inside of main chords PROUDLY MADE IN THE U S A 722 Blue Crab Road Newport News VA 23606 757 591 9371 fax 757 591 9514 www appliednn com REVISED 10 24 2017 ...