24
Your
Magnum 7500 Corn/Wood Pellet Furnace
comes to you with the glass door installed in place,
ready for use. The glass is surrounded on the edges with a gasket and seated in a glass channel. It is held
in place with two (2) clips on the top and (2) clips on the bottom
REMOVAL OF BROKEN OR DAMAGED GLASS
Open the door and lift off of hinges. If the door is tight, tap gently on the bottom of the door with your
hand or rubber hammer. Lay door down on newspaper with glass clips facing you. Using a #2 Phillips
screwdriver, loosen the screws and take off the glass clips. Remove the broken glass carefully and
discard.
Check to make sure that the gasket material under the glass is in good shape. You can get this material
from the factory or from an authorized
Magnum 7500
reseller if it needs to be replaced.
Reverse the above procedure for replacing new glass.
When installing the new glass make sure that
the glass is not sitting binding or hitting any corners. If the glass touches any of the casting when
tightening it will break.
CLEANING THE GLASS
When the fire is first started, it will produce some smoke. The smoke might accumulate on the glass
surface. Before the fire gets hot, open the door and wipe the glass surface off with a damp rag. Do not
touch the surface with your hands. If after constant use, the glass is dirty; you must clean the glass so that
it will not become etched with the fly ash. When the glass has cooled off, take a damp rag, put a little fly
ash from the unit on it and clean the glass. If this does not clean the glass use a special glass cleaner
provided by your
Magnum 7500
reseller.
We have found that Amway crème glass & chrome cleaner
works real well.
Glass Spacer Clip
One each side
GLASS MAINTENANCE, ADJUSTMENT, REMOVAL AND REPLACEMENT
WARNING
Do no operate unit with broken glass.
Do not substitute original factory glass.
You must use only factory authorized glass:
(8.680” x 15.125” high temperature Ceramic glass, 5mm thick)
Do not slam door shut.
Do not strike glass.
Do not use abrasive cleaners.
Do not clean when glass is hot.
GLASS CLIPS
