2
309887
WARNING
FUEL HAZARD
The fuel used in this equipment is flammable. When spilled on a hot surface it can ignite and cause a
fire. Do not fill fuel tank while engine is running or hot.
INJECTION HAZARD
Spray from gun, leaks or ruptured components can inject fluid into your body and cause an extremely
serious injury, including the need for amputation. Splashing fluid in the eyes or on the skin can also
cause serious injury.
D
Fluid injected into the skin might look like just a cut, but it is a serious injury.
Get immediate medi-
cal attention.
D
Do not point gun at anyone or any part of the body.
D
Do not put hand or fingers over the spray tip, and do not stop or deflect fluid leaks with your hand,
body, glove or rag.
D
Do not “blow back” fluid; this is not an air spray system.
D
Always have tip guard and trigger guard on gun when spraying.
D
Engage trigger safety whenever you stop spraying.
D
Follow the
Pressure Relief Procedure
on page 4 when you are instructed to relieve pressure;
stop spraying; check, clean, or service any system equipment; or install or change spray tips.
D
Tighten all fluid connections before each use.
D
Check the hoses, tubes and couplings daily. Replace worn or damaged parts immediately. Perma-
nently coupled hoses cannot be repaired.
D
Handle and route hoses and tubes carefully. Keep hoses and tubes away from moving parts and
hot surfaces. Do not use the hoses to pull equipment. Do not expose ASM hoses to temperatures
above 150
_
F (65
_
C) or below –40
_
F (–40
_
C).
TOXIC FLUID HAZARD
Hazardous fluid or toxic fumes can cause serious injury or death if splashed in the eyes or on the
skin, inhaled, or swallowed.
To help prevent injury or death from toxic fluids
D
Know specific hazards of fluid you are using; store hazardous fluid in approved tub; dispose of
hazardous fluid according to all local, state, and national guidelines.
D
Always wear protective eyewear, gloves, clothing, and respirator as recommended by fluid and
solvent manufacturer.
FLUID SPLASHBACK HAZARD
To avoid splashback of fluid while spraying, make sure the spray gun is assembled with the correct
gasket for the fluid being sprayed.
EXHAUST HAZARD
The exhaust contains poisonous carbon monoxide which is colorless and odorless. Do not operate
this equipment in a closed building.
