Advance acoustic Exterra 56507000, Quick Start Troubleshooting Manual

Page: 14 / 89

14 - FORM NO. 56043110 - Exterra
™
Copyright 2007 Nilfisk-Advance.
Page 1 of 2
2/21/2007
Exterra
PM Checklist
Defect Codes
Customer
A needs adjustment
B binding
Address
C dirty or contaminated
D damaged, bent or torn
City
St Zip L leaks
M missing
Model
Serial Hours W worn out
Ref
OPERATIONAL INSPECTION ITEMS
OK
Defect Codes
(circle)
Does
Not
Work
1 Check Neutral Safety/Sense Switch operation (To test depress drive pedal and start the
engine, it should not start.)
A B C
2 Engine Starting with pedal in neutral (if it will not start check sensor switch
programming)
starts hard
3 Engine Speeds 3 cyl G/P (note electrical actuator throttle linkage 1500 - 2800 RPM) A rough
4 Engine Speeds 4 cyl G/P (1200 - 2400 RPM) A low power
5 Engine Speeds Diesel (note electrical actuator linkage 1200 - 2400 RPM)
6 Drive Pedal Linkage (check for FWD/REV drive and any neutral creep) A B
7 Drive System Performance noisy sluggish
8 Brakes (check both service & parking) A B W
9 Steering excessive play
10 Hopper Up/Down (also check operation of the safety hopper support) A B
11 Hopper Dump Door Open/Close A B
12 Main Broom Raise /Lower <----->
13 Side Broom Raise /Lower <----->
14 Main Broom On/Off <----->
15 Side Broom On/Off <----->
16 Headlights, Gauges and Optional Accessories (example rotating beacon, backup alarm)
17 Dust Control Filter Shaker & Vacuum Impeller
<----->
18 Tilt Steering Mechanism and Seat Adjustment lever A B
19 Dust Guard (OPT) Water Pump Operation On/Off
Ref
VISUAL INSPECTION ITEMS
Comments OK
Defect Codes
(circle)
Does
Not
Work
20 Side Broom Pattern & Height Adj. (min bristle wear 3 inches) 3 O'clock to 11 A B D W
21 Side Broom Motor B L
22 Hopper Cover Gasket D W
23 Hopper Dust Filter & Gasket D W
24 Dust Control Vacuum Impeller Motor L
25 Hopper Dump Door Cylinder A B L
26 Hopper Skirting & Seals (raise hopper to inspect) D M W
27 Hopper Dump Door & Seal (raise hopper to inspect) A B D W
28 Hopper Lift Cylinder & Hopper Interlock Switch Magnetic Switch A B L
29 Main Broom Pattern Adjustment (min bristle wear 2-1/2"
6.4cm length)
2-3" (5-7 cm) wide
pattern
A B D W
30 Main Broom Motor (open left side access door to inspect) B L
31 Broom Housing & Door Skirts D M W
32 Front tires (check lug nut torque 80FT LB, 108 Nm) Tire Pressure 90 psi L W
33 Battery Clean & Water C W
34 Engine Air Cleaner Element (inner & outer) Check SVR Indicator C W