4
PRECAUTIONS
'2 127 86( 7+,6$33/,$1&( ,)$1< 3$57 +$6 %((1
(;326('72)/22',1*25:$7(5'$0$*(,PPHGLDWHO\
FDOODTXDOL¿HGVHUYLFHDJHQF\WRLQVSHFWWKHDSSOLDQFHDQGWR
PDNHDGHWHUPLQDWLRQRQZKDWVWHSVVKRXOGEHWDNHQQH[W
,IWKHXQLWLVH[SRVHGWRWKHIROORZLQJGRQRWRSHUDWHKHDWHU
XQWLO DOO FRUUHFWLYH VWHSV KDYH EHHQ PDGH E\ D TXDOLILHG
VHUYLFHDJHQF\
([WHUQDO¿UH
'DPDJH
)LULQJZLWKRXWZDWHU
GROUNDING INSTRUCTIONS
7KLV ZDWHU KHDWHU PXVW EH JURXQGHG LQ DFFRUGDQFH ZLWK WKH
1DWLRQDO(OHFWULFDO&RGHDQGRUORFDOFRGHV7KHVHFRGHVPXVW
EH IROORZHG LQ DOO FDVHV )DLOXUH WR JURXQG WKLV ZDWHU KHDWHU
SURSHUO\PD\DOVRFDXVHHUUDWLFFRQWUROV\VWHPRSHUDWLRQ
7KLV ZDWHU KHDWHU PXVW EH FRQQHFWHG WR D JURXQGHG PHWDO
SHUPDQHQWZLULQJV\VWHPRUDQHTXLSPHQWJURXQGLQJFRQGXFWRU
PXVW EH UXQ ZLWK WKH FLUFXLW FRQGXFWRUV DQG FRQQHFWHG WR WKH
HTXLSPHQWJURXQGLQJWHUPLQDORUOHDGRQWKHZDWHUKHDWHU
HYDROGEN GAS FLAMMABLE
+\GURJHQ JDV FDQ EH SURGXFHG LQ D KRW ZDWHU V\VWHP VHUYHG
E\WKLVZDWHUKHDWHUWKDWKDVQRWEHHQXVHGIRUDORQJSHULRGRI
WLPHJHQHUDOO\WZRZHHN\GURJHQJDVLVH[WUHPHO\
ÀDPPDEOH7RUHGXFHWKHULVNRILQMXU\XQGHUWKHVHFRQGLWLRQV
LWLVUHFRPPHQGHGWKDWDKRWZDWHUIDXFHWVHUYHGE\WKLVZDWHU
KHDWHUEHRSHQHGIRUVHYHUDOPLQXWHVEHIRUHXVLQJDQ\HOHFWULFDO
DSSOLDQFH FRQQHFWHG WR WKH KRW ZDWHU V\VWHP ,I K\GURJHQ LV
SUHVHQW WKHUH ZLOO SUREDEO\ EH DQ XQXVXDO VRXQG VXFK DV DLU
HVFDSLQJWKURXJKWKHSLSHDVWKHZDWHUEHJLQVWRÀRZ
THERE
6+28/' %( 12 602.,1* 25 23(1 )/$0( 1($5 7+(
)$8&(7$77+(7,0(,7,623(1
GENERAL SAFETY INFORMATION
Read and understand this instruction
manual and the safety messages
herein before installing, operating or
servicing this water heater.
Failure to follow these instructions and
safety messages could result in death
or serious injury.
This manual must remain with the
water heater.
Water temperature over 125°F (52°C)
can cause severe burns instantly
resulting in severe injury or death.
Children, the elderly and the
physically or mentally disabled are at
highest risk for scald injury.
Feel water before bathing or
showering.
Temperature limiting devices such as
mixing valves must be installed
when required by codes and to
ensure safe temperatures at fixtures.
Explosion Hazard
Overheated water can cause
water tank explosion.
Properly sized temperature and
pressure relief valve must be
installed in the opening provided.
Verify the power to the water heater is turned off before performing any service procedures.
The Enable /Disable switch on front panel disables the 24 volt gas valve. Electrical supply
must be turned off at circuit breaker serving water heater.
Improper installation, use and service may result
in property damage.
Do not operate water heater if exposed to flooding or
water damage.
•
Inspect anode rods regularly, replace if damaged.
•
Install in location with drainage.
•
Fill tank with water before operation.
•
Properly sized thermal expansion tanks are required on all
closed water systems.
•
Refer to this manual for installation and service.
CAUTION
Explosion Hazard
Flammable hydrogen gases
may be present.
Keep all ignition sources away
from faucet when turning on
hot water.
Summary of Contents for BTH 300
Page 66: ...66 WIRING DIAGRAM Figure 58 ...
