TOTAL DYNAMIC HEAD FLOW PER
MINUTE @ 12.1
VOLTS
© Copyright 2022 Zoeller
®
Co. All rights reserved.
502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | zoellerpumps.com
Shipping weight: 17 lbs. (7.7 kg)
NOTE: Not recommended for installation with over 20' (6 m) Total Dynamic
Head.
Performance chart based upon actual performance achieved with a 12 volt
deep-cycle battery. Some manufacturers publish performance data based upon
D.C. pump testing according to marine industry standards which can reflect a
performance of 40% - 80% higher than actual battery powered performance.
See FM3166 (Aquanot
®
Spin 508) Installation Instructions.
Minimum pit size recommendation: 18" (46 cm) diameter X 22" (56 cm)
deep. Minimum battery requirements: deep-cycle, size 27, 175 minute
reserve capacity.
152944
WARRANTY
3 years from date of purchase. Battery warranty is 3 years.
BATTERY LIFE
The estimated life of a fully charged (175 minute reserve capacity)
battery when the pump is operating continuously is approximately
5.5 hours. However, most backup system pump operation is
intermittent.The system will provide protection for extended periods
of time dependent upon stop-start requirements and multiple
battery arrangements.
PERFORMANCE DATA
Pump performance is based on the use of a fully charged 12 volt,
(200-minute reserve capacity) deep-cycle battery with no deficiency
and less than two years old.
AQUANOT
®
BATTERY
•
Size 31 “Wet” P/N 10-0761 (58 lbs. [27 kg]) (shipped via
truckline only) 180-minute reserve capacity
•
Size 27 “AGM” P/N 10-1450 (57 lbs. [26 kg]) 180-minute
reserve capacity
•
Size 27 "Wet" P/N 10-5105 (53 Ibs [24 Kg]) (shipped via truckline
only) 140-minute reserve capacity.
TOTAL DYNAMIC HEAD/FLOW
PER MINUTE
EFFLUENT AND DEWATERING
22ft. (6.7m)
508
Shut-off Head:
MODEL
15
10
Feet
5
4.6
3.0
30
20
1.5
Meters
39
Gal.
76
114
148
Liters
20
6.1
6
23
FLOW PER MINUTE
LITERS 0
80
5
25
15
10
GALLONS
TOT
AL
DYNAMIC HEAD
0
2
4
6
10
20
30
160
40
50
FEET
METERS
20
8
PUMP PERFORMANCE CURVE
MODEL 508 @ 12.1 VOLTS
TOTAL DYNAMIC HEAD/FLOW
PER MINUTE
EFFLUENT AND DEWATERING
22ft. (6.7m)
508
Shut-off Head:
MODEL
15
10
Feet
5
4.6
3.0
30
20
1.5
Meters
39
Gal.
76
114
148
Liters
20
6.1
6
23
FLOW PER MINUTE
LITERS 0
80
5
25
15
10
GALLONS
TOT
AL
DYNAMIC HEAD
0
2
4
6
10
20
30
160
40
50
FEET
METERS
20
8
PUMP PERFORMANCE CURVE
MODEL 508 @ 12.1 VOLTS
All installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be
followed including the most recent National Electrical Code (NEC) and the Occupational Safety and Health Act (OSHA).
CAUTION
SK3182
1" MIN.
IMPORTANT: OFF LEVEL
OF FLOAT ASSEMBLY
MUST BE HIGHER THAN
DC BACKUP PUMP
FIG. 1
DC PUMP INSTALLED IN LINE WITH SUBMERSIBLE PUMP
BATTERY BOX
AQUANOT SPIN CONTROLLER
OUTLET
PRIMARY PUMP
OUTLET
CONTROLLER
HI-WATER
REED SENSOR
(*OPTIONAL)
Model
System
Warranty
508-0005
Aquanot
®
Spin 508
3 Years
508-0006
Aquanot
®
Spin 508/
M53 ProPak
3 Years
508-0007
Aquanot
®
Spin 508/
M98 ProPak
3 Years
SYSTEMS
