Usage
Technical Assistance
Our Customer Service Department is eager to help you with any questions or
issues you may have and are available from 8:30AM to 5:30PM, Monday thru
Friday at 865-688-5953. In addition, technical support is available via FAX at
865-281-9844 or by email at [email protected]. Be sure to check out
our website for additional technical and product information.
The following damage is specifically excluded:
Over discharge below 9V for 12V models, 10.8V for 14V or 12.6V for 16V models
open circuit voltage.
Overcharge above 14.5V for 12V models, 17.4V for 14V models or 20.3V for 16V
models.
Capacity is not guaranteed (ie. if the battery still accepts energy and discharges
energy, it is considered “good”)
Internal resistance is not guaranteed. (ie. if the battery was at 4milliΩ new and
now is 6, 8, 10 or greater milliΩ internal resistance, it is considered “good”)
Water damage and resulting internal corrosion.
Physical damaged such as case cracks from drops, impacts, or crushing it with
a battery mount.
To reduce the risk of fire or personal injury including burns:
Do not over charge the battery (meaning exceed the maximum voltage OR
amperage and remove the charger once the battery is at 100% SOC.)
Do not short circuit the terminals.
Use with alternators requires that the charging voltage be limited to 14.5V or less.
13.0~14.0 is preferred for 12V models, 15.5-17.4 for 14V models and 18.2-20.3-
for 16V models.
Avoid high temperature. Never operate the battery in environments above 140oF
or if the battery itself exceeds 140oF at any point.
Disconnect the battery in total before welding anywhere on the vehicle.
Do not submerse in water. This battery is not waterproof.
Do not crush, puncture, or dispose in fire or water.
Do not attempt to open, disassemble, or service the battery pack.
Warnings
Warranty
More specifically this text applies:
This limited warranty shall not apply to damage to or failure of a product that results from: (i) any
negligence other than by XS Power; (ii) accident (including, but not limited to, damage during shipment
and natural disasters); (iii) other circumstances beyond XS Powers’ control (including, but not limited
to, normal capacity loss or increased resistance due to product aging); (iv) improper installation,
operation (including, but not limited to, abnormal or non-consumer use or use in an environment
outside the recommended temperature range), maintenance, or storage (including, but not limited to,
storage in an overly discharged state); or (v) any other damage directly or indirectly caused by the
product’s owner, other third parties, or other products (including, but not limited to, misuse, abuse,
overcharging, over-discharging, exceeding of the product’s limitations set forth in the product’s
specification sheet or label, neglect, physical damages caused by accidents or crashes, alterations, or
connection to poorly-grounded battery chargers). This limited warranty shall also not apply to defects
or non-conformities due to the manufacturing process discovered after the expiration of the applicable
warranty period. This warranty does not extend to any damage caused by affixing any parts or
equipment not purchased from XS Power to the product and no warranties, either express or implied,
are made with respect to equipment or products not produced by XS Power. If the product is relocated
outside of the continental United States during the applicable warranty period, the product’s owner will
be responsible for any additional charges (including, but not limited to, shipping and other related
charges and expenses) incurred during the warranty process as a result of such relocation.
In general, the lithium battery will greatly outperform the lead acid battery it is
replacing. If it does not, chances are you have a battery that is too small for
the job. It may be necessary to use a larger capacity battery, or and a second
battery in parallel. Pulling the battery’s terminal voltage below 9V(12V
models), 10.8V(14V models), or 12.6V(16V models) for even the shortest
amount of time is prone for a premature failure.
Lithium batteries have a relatively flat discharge curve when compared to a
lead acid battery. The average terminal voltage throughout discharge will be
12.0V for 12V models, 14.4V for 14V models or 16.8V for 16V models.
Unfortunately, this can make judging the state of charge difficult when the
battery is nearly empty. Lithium batteries at a low state of charge will show a
relatively high voltage. It is important to get familiar with the limits of your
battery because over discharge (discharge below 9V for 12V models, 10.8V
for 14V models, or 12.6V for 16V models) must be strictly avoided.
*S5 Titan8 shown. All details on each model are the same the only difference is the length of each battery.
Features
1
2
3
3
4
5
6
7
8
9
9
Bottom View
Top View
1 - Top Positive Terminal
2 - Top Negative Terminal
3 - Side Terminals Corresponding with
Top Terminals
4 - Set Screws for 0 AWG and 00 AWG
Wire Connections
5 - Wire Chase Cover
6 - Wire Chase Screw
7 - Negative 0 AWG and 00 AWG Wire
Connections
8 - Positive 0 AWG and 00 AWG Wire
Connections
9 - Battery Mounting Holes
