10
OPM-109
REV B
Open skid mounted Diesel units are often supplied with capped inlet
DQGUHWXUQOLQHV7KHXVHRIDVXVWDLQDEOHFXVWRPHUVXSSOLHGÀH[LEOH
fuel line is essential between the engine and fuel supply to provide a
vibration break between your fuel supply and the engine.
LUBRICATION
Before starting the engine, check the oil level in the crankcase. If
LWLVORZUH¿OOWRWKHIXOOPDUNZLWKWKHSURSHUZHLJKWJUDGHRIRLODV
recommended by the engine manufacturer’s maintenance instructions.
The necessity of using the correct oil, and keeping the crankcase full,
FDQQRWEHRYHUHPSKDVL]HG)DLOXUHWRXVHWKHSURSHURLODQGNHHSWKH
FUDQNFDVHSURSHUO\¿OOHGZLOOFDXVHH[FHVVLYHHQJLQHZHDUDQGVKRUWHQ
its useful life.
DR20I4 & DR30I4
DR45F4 - DR130F4
INSTALLING THE BATTERY
CAUTION:
In the following battery installation procedure, check to be sure the
'6(0.,,LVLQWKH³VWRS´SRVLWLRQ7KLVVKRXOGEH\RXUODVWVWHS
EHIRUHLQLWLDOVWDUWXS
A customer supplied Group 24/350 CCA battery is required to complete
the installation. Installation of the highest CCA rated battery, within the
correct BCI group, will increase cold weather starting performance.
BATTERY REQUIREMENTS
Model
Voltage
BCI Group Min. CCA Rating
DR20I4 - DR65F4
12
24
650
DR90F4 - DR130F4
12
31
900
Installation and servicing of batteries must only be preformed or
supervised by personnel knowledgeable of batteries and the required
SUHFDXWLRQV.HHSXQDXWKRUL]HGSHUVRQQHODZD\IURPEDWWHULHV
:KHQLQVWDOOLQJRUUHSODFLQJEDWWHULHVXVHWKHSURSHUJURXSVL]H
starting battery. The battery should be a maintenance-free lead acid
design. Deep cycle batteries will not work for this application.
CAUTION: PERSONAL DANGER:
NEVER
GLVSRVHDEDWWHU\LQD¿UH7KHEDWWHU\LVFDSDEOHRIH[SORGLQJ
DO NOT open or mutilate the battery. Released electrolyte is known to
be harmful to the skin and eyes and to be very toxic.
These engine-generator sets are all NEGATIVE ground. Be very careful
not to connect the battery in reverse polarity, as this may short circuit
the battery charging system on the engine.
CAUTION:
A battery presents a risk of electrical shock and high short circuit
current. The following precautions must be observed when working
with batteries:
5HPRYHZDWFKHVULQJVDQGRWKHUPHWDOREMHFWV
2. Use tools with insulated handles.
&KHFNERWKWKHEDWWHU\FDEOHHQGVDQGWKHEDWWHU\SRVWVWREH
sure they are free of corrosion.
$OZD\VFRQQHFWWKHEDWWHU\SRVLWLYHFDEOH¿UVWDQGWKHQFRQQHFW
the battery negative cable. When removing the battery cables
from the battery, reverse the procedure, disconnect the negative
¿UVWDQGWKHQWKHSRVLWLYHFDEOH
5. Be sure all connections are tight and coat the terminals and cable
ends with dialectic grease.
WARNING:
The electrolyte is diluted sulfuric acid that is harmful to the skin
and eyes. It is electrically conductive and corrosive. The following
precautions must always be taken.
$OZD\VZHDUIXOOH\HSURWHFWLRQDQGSURWHFWLYHFORWKLQJ
2. Where electrolyte contacts skin, wash off immediately with water.
,IHOHFWURO\WHFRQWDFWVWKHH\HVÀXVKWKRURXJKO\DQGLPPHGLDWHO\
with water and seek immediate medical attention
6SLOOHGHOHFWURO\WHLVWREHZDVKHGGRZQZLWKDQDFLGQHXWUDOL]LQJ
agent. A common practice is to use a solution of one pound
RIELFDUERQDWHRIVRGDEDNLQJVRGDWRRQHJDOORQRIZDWHU
The bicarbonate of soda solution is to be added until the evidence
RIUHDFWLRQIRDPLQJKDVFHDVHG7KHUHVXOWLQJOLTXLGLVWREH
ÀXVKHGZLWKZDWHUDQGWKHDUHDGULHG
DANGER: EXPLOSIVE FIRE RISK:
1HYHUVPRNHZKHQQHDUEDWWHULHV
'RQRWFDXVHDÀDPHRUVSDUNLQWKHEDWWHU\DUHD
$OZD\VGLVFKDUJHVWDWLFHOHFWULFLW\IURP\RXUERG\EHIRUHWRXFKLQJ
EDWWHULHVE\¿UVWWRXFKLQJDJURXQGPHWDOVXUIDFH
SERVICING BATTERIES
Batteries used on these units may, over time, lose water. This
is especially true if you are using a trickle charger to maintain
your battery. Different types of batteries require various types
