UPS-Division
Operating Manual Wärtsilä JOVYLINE 625/1200/2200 BAX 3522 E page 14
9. Replacing the batteries
The battery works at least 3 years faultless before its replacing is necessary.
For replacing please act as following:
Secure that the UPS is switched-off, that the UPS is disconnected from mains and
that each leaving wires such as load, EDV, telephone etc. are disconnected.
1. Remove the 4 screws at the UPS bottom sheet and store them.
2. Remove the upper cover sheet carefully. Don’t touch parts inside the UPS before you
have disconnect the battery.
3. Remove the battery connection cables from the battery poles.
4. Now you can remove the battery easily.
Attention:
Lead the battery to a suited recycling circle. Don’t throw the battery into fire
(danger of explosion). Avoid short circuit of the battery poles (danger of burns
and explosion). Before works take off every decoration things such as rings,
bracelets etc. (danger of short circuit and burns)
5. Place the new batteries in the same position as the old ones.
Connect the battery wiring to the battery again. + = red wiring, - = black wiring
6. Screw on the cap of the cabinet.
7. Follow the instructions of the manual to put the UPS into operation again.
10. Troubleshooting
Problem
Possible
reason
Solution
UPS doesn’t start
ON/OFF push button isn’t pressed
push the button 1 sec
LED doesn’t lighten
or pressed
to
short
at
least
Battery voltage is lower than 10 V
load the battery
4
hours
at
least
UPS only works in
mains cable is loose
put in the mains cable
battery operation
AC fuse defect
change the fuse
Mains voltage is to high
establish normal
mains voltage
faults in the electronic system
dial our service hotline
time of emergency -
battery isn’t charged completely
charge the battery
current
is
to
short
4
hours
at
least
faults in the electronic system
dial service hotline
buzzer
on
permanent
overload
remove
unimportant
alarm
loads
Red LED lightens up
battery fault
replace the battery
UPS doesn’t feed load
load is connected at the wrong
use the both socket
socket
as
described
in
item
11
socket: „surge protection“
page 10
