A S S E M B LY • O P E R AT I O N • WA R R A N T Y
5
Waterworks
Division
P: 866 - 987-7297 F: 813-621-7125
Visit us at www.ussaws.com
5.0 ASSEMBLY
This unit comes fully assembled
6.0
GENERAL INFORMATION
The purpose of this manual is to assist you in assembling, operating
and maintaining your sprayer. Please read it carefully as it furnishes
information which will help you achieve years of dependable trouble-
free operation.
7.0 WARRANTY/PARTS/SERVICE
Products are warranted for one year from date of purchase against
manufacturer or workmanship defects.
Your authorized dealer is the best source of replacement parts and
service. To obtain prompt, efficient service, always remember to give
the following information:
1.
Correct part description and part number.
2.
Model number of your sprayer.
Part description and part numbers can be obtained from the illus-
trated parts list section of this manual.
Whenever you need parts or repair service, contact your distributor /
dealer first. For warranty work always take your original sales slip, or
other evidence of purchase date, to your distributor/ dealer.
8.0
BATTERY CHARGING
It is recommended to charge the battery for 8-10 hours before using,
or if the battery has been stored for 6 or more months without usage.
Once fully charged you should be able to spray 40 gallons of fluid, or
8 consecutive tanks.
To charge the battery ...
1.
Plug the charger into a 110 Volt AC electrical receptacle.
2.
Insert the plug on the opposite end of the charger into the
charging jack located on the back panel of the sprayer.
3.
Reverse the above steps when charging is complete.
CAUTION: Never leave the charger connected to the battery for more
the 20 hours, as this may damage the battery.
9.0 OPERATION
This sprayer is designed to be pulled or pushed by hand.
Pour solution into the tank and stir to mix. For liquid chemicals it is
possible to mix by spraying the handgun into the tank.
Turn the switch to the “ON” position and spray by squeezing the lever
on the handgun. The unit is supplied with a demand pump that will
only operate while the lever on the handgun is depressed.
10.0
TROUBLE SHOOTING
Pump will not run:
1. Check inline fuse on the wiring harness. If blown or damaged
replace with a new 5 Amp fuse.
2. Insure the battery is fully charged.
3. Check that the on/off switch is in the on position
4. Insure that strainer located on bottom of tank is free of debris.
11.0
AFTER SPRAYING
After use fill the sprayer part way with water. Start the sprayer and
allow clear water to be pumped through the plumbing system and out
through the spray wand. Refill the tank about half full with plain water
and use a chemical neutralizer such as Nutra-Sol® or equivalent and
repeat cleaning instructions. Flush the entire sprayer with the neutral-
izing agent. Follow the chemical manu facturer’s disposal instructions
of all wash or rinsing water.
12.0
WINTER STORAGE
Drain all water and chemical out of sprayer, pay ing special attention
to pump and valves. These items are especially prone to damage from
chemicals and freezing weather. The sprayer should be winterized
before storage by pumping a solution of RV antifreeze through the
entire plumbing. Proper care and maintenance will pro long the life of
the sprayer.