Operation
After Operation
General Safety
•
Park machine on level ground and allow the
machine to cool. Never allow untrained personnel
to service machine.
•
Disengage the spray or close the spreader gate, set
the parking brake, stop engine and remove key or
disconnect spark plug wire. Wait for all movement
to stop before adjusting, cleaning or repairing.
•
Clean the machine as stated in the Maintenance
section.
•
Frequently check for worn or deteriorating
components that could create a hazard. Tighten
loose hardware.
•
Shut off fuel while storing or transporting. Do
Not store fuel near flames or drain indoors.
Transporting
Note:
Refer to the chemical warning product
label(s) before transporting the machine and follow
all local/state/federal requirements for transporting
chemicals.
Note:
Make sure the spreader hopper cover and the
spray wand are secure before transporting.
Transporting the Machine
Use a heavy-duty trailer or truck to transport the
machine. Ensure that the trailer or truck has all
necessary lighting and marking as required by law.
Thoroughly read all of the safety instructions.
Knowing this information could help you, your
family, pets, or bystanders avoid injury.
To transport the machine:
•
Lock the brake and block the wheels.
•
Securely fasten the machine to the trailer or
truck with straps, chains, cable, or ropes. When
securing the front of the machine, only use
the tie down locations shown in Figure 34 and
Figure 35. If possible, both front and rear straps
should be directed down and outward from the
machine. Using non-designated locations may
cause damage to the machine and/or attachment.
g314318
Figure 34
42 and 46 Inch Models
1.
Tie down location
g314317
Figure 35
52 Inch Models
1.
Tie down location
WARNING
Securing the machine on any upper frame
location will cause the parking brake to not
function properly, which could cause serious
injury or death.
Only use the front tie down locations on the
lower frame to secure the machine.
•
Secure a trailer to the towing vehicle with safety
chains.
WARNING
Driving on the street or roadway without turn
signals, lights, reflective markings, or a slow
moving vehicle emblem is dangerous and can
lead to accidents causing personal injury.
Do not drive machine on a public street or
roadway.
40
