Servicing the
Diesel-Oxidation Catalyst
(DOC) and the Soot Filter
Service Interval:
Every 6,000 hours or clean the soot
filter if engine faults
SPN
3720
FMI
16,
SPN
3720
FMI
0, or
SPN
3720
FMI
16 display in the InfoCenter.
•
If advisory message
ADVISORY
179 displays in the
InfoCenter, the DPF is nearing the recommended
point for servicing the diesel-oxidation catalyst and
the soot filter.
g213865
Figure 53
•
If engine faults
CHECK ENGINE SPN
3251
FMI
0,
CHECK ENGINE SPN
3720
FMI
0, or
CHECK ENGINE
SPN
3720
FMI
16in the InfoCenter (
)
display in the InfoCenter, clean the soot filter using
the steps that follow:
g214715
g213864
g213863
Figure 54
1.
Refer to the Engine section in the
Service
Manual
for information on disassembling and
assembling the diesel-oxidation catalyst and
the soot filter of the DPF.
2.
Refer to your Authorized Toro Distributor for
diesel-oxidation catalyst and the soot filter
replacement parts or service.
3.
Contact your Authorized Toro Distributor to
have them reset the engine ECU after you
install a clean DPF.
Fuel System
Maintenance
Note:
Refer to Adding Fuel for proper fuel
recommendations.
DANGER
Under certain conditions, diesel fuel and fuel
vapors are highly flammable and explosive. A
fire or explosion from fuel can burn you and
others and can cause property damage.
•
Use a funnel and fill the fuel tank outdoors,
in an open area, when the engine is off and
is cold. Wipe up any fuel that spills.
•
Do not fill the fuel tank completely full. Add
fuel to the fuel tank until the level is to the
bottom of the filler neck.
•
Never smoke when handling fuel, and stay
away from an open flame or where fuel
fumes may be ignited by a spark.
•
Store fuel in a clean, safety-approved
container and keep the cap in place.
Servicing the Water
Separator
Service Interval:
Every 400 hours
Drain water or other contaminants from water
separator (
) daily. Replace filter canister
after every 400 hours of operation.
1.
Place a clean container under the fuel filter.
2.
Loosen the drain plug on the bottom of the filter
canister and open the vent on the top of the
canister mount.
g007367
Figure 55
1.
Water separator filter canister
3.
Clean the area where the filter canister mounts.
46
Содержание Groundsmaster 360 31200 Series
Страница 58: ...Notes...
Страница 59: ...Notes...
