TOHATSU MFS 6BZ, Руководство пользователя

Страница: 81 / 88

INSPECTION AND MAINTENANCE
81
10
5. Recharge the battery once a month
to prevent it from discharging and
the electrolyte from deteriorating.
6. Store the battery in a dry place.
ENOM00104-A
The following steps must be taken when
first using the engine after off-season
storage.
1. Check that the shift and throttle
function properly. (Be sure to turn
the propeller shaft when checking
the shift function or else the shift
linkage may be damaged.)
2. Check the electrolyte level, and mea-
sure the voltage and specific gravity
of the battery.
3. Check that the battery is secure and
the batter y cables are proper ly
installed.
4. Change the engine oil (See page 68).
5. Before starting the engine, discon-
nec t stop switch lock and crank
approximately 10 times in order to
prime the oil pump.
6. Fill fuel tank completely.
7. Start the engine and warm up the
engine for 3 minutes in the “NEU-
TRAL” position.
8. Run the engine for 5 minutes at the
slowest speed.
9. Run the engine for 10 minutes at half
throttle. The oil used for storage
inside the engine will be circulated
out to assure optimum performance.
ENOM00105-A
ENOW00098-0
Do not attempt to start submerged outboard
motor immediately after it is recovered, or
engine could be severely damaged.
After taking your outboard motor out of
the water, immediately take it to your
dealer.
The following are the emergency mea-
sures to be taken for a submerged out-
board motor, if you can not take it your
dealer right away.
1. Wash the outboard motor with fresh
water to remove salt or dirt.
2. Remove the engine oil drain screw
and completely drain water and oil
from the engine.
3. Remove the spark plugs, and com-
pletely drain the water from the
engine by pulling recoil starter sev-
eral times.
Replace oil filter and oil to the cor-
rect level.
The oil and filter may need to be
changed again after running a short
period to get all moisture completely
out of the crankcase.
4. Inject a sufficient amount of engine
oil through the spark plug holes.
Pull the recoil starter rope several
times to circulate the oil throughout
the outboard motor.
4. Pre-season check
Specific Grav-
ity at 20°C
Terminal Volt-
age (V)
Charge Condi-
tion
1.120 10.5
Fully
discharged
1.160 11.1 1/4 charged
1.210 11.7 1/2 charged
1.250 12 3/4 charged
1.280 13.2 Fully charged
5. Submerged outboard motor
CAUTION