stertil-KONI ST 1065-FWF, Руководство по обслуживанию и запасным частям

Страница: 32 / 132

Service and Parts manual (Version B) 32 Wireless
1. All daily and monthly inspections as described in the Operation Manual and
Monthly maintenance (on page 31)
2. Check the pneumatic spring as described in section Checking the pneumatic
spring(s) (on page 35) .
3. Check oil level. The oil level in the tank of the hydraulic unit must be above the
minimum oil level line when the column is completely raised. The oil level must be
above the minimum oil level line, but not more than 3 cm above this line.
4. When the oil level is too low, always perform the leak checks described later in this
chapter.
5. Inspection of all safety features.
6. Check for leakage from the cylinders. If oil is leaking from one of the cylinders, the
seals and the guide rings must be replaced.
7. Check for leakage from the hydraulic system. If the column lift sinks back down by
more than 6 mm per hour, then the system must be inspected for external (hoses,
couplings) and internal (valves) leakage. Defective parts must be replaced.
8. General inspection for damage. If cracks have appeared in structural components,
then the parts in question must be replaced. Immediately repair or replace all parts
which could cause hazardous situations.
9. Perform all lubrication tasks set out in section Lubrication instructions (on page
32) .
For additional details, see chapter Troubleshooting (on page 67) .
5.5 Regular preventive maintenance procedures
5.5.1 Lubrication instructions
The vehicle lifts must be serviced regularly in accordance with the lubrication
instructions.
Table 2: Lubrication instructions
Maintenance tasks Description Monthly Per year
(technical
service)
Every
2 years
(technical
service)
Cylinder Lubricate dry piston-rod
(machine oil).
X
Check oil level in
tank
Top up (only with column
lifts fully lowered).
X
Various pivot points Lubricate.
X
Hydraulic oil in the
tank
Replace; see section
Hydraulic oil (on page
33) .
X
Suction filter Clean or replace. X
Safety lock Check and clean if
required.
X