Section 16
HULL/BODY
Subsection 02
(ADJUSTMENT AND REPAIR)
SMR2003-046_16_02A.FM
16-02-39
Assembly
Before assembly verify the physical condition of
cylinder groove and adjustment holes.
1. Groove
2. Adjustment holes.
Align groove with stopper screw, while inserting
the cylinder into housing.
Tighten the stopper screw.
Installation
Before Installation, make sure:
– inside cylinder slides up and down freely with-
out obstruction from grab handle
– saftey lock pin operates properly
– stopper screw stops cylinder at its most up-
wards position.
To Install the wake post
no. 20,
reverse removal
procedure.
GTX DI and GTX 4-TEC Series Models
Remove trim
no. 1
from side bumper rail
no. 2
.
Remove screws
no. 4
to remove side bumper rail
no. 2
.
Mark hole positions on body straight and bow sec-
tions.
TYPICAL
1. Front bumper
2. Corner bumper
3. Straight section
4. Bow section
Slide bumper rail
no. 2
under front bumper
no. 6
.
Using a 4.80 mm (3/16 in) drill bit, drill first hole
through bumper rail
no. 2
at front of bow section.
CAUTION:
When drilling, be careful not to
damage bumper rail and/or hull.
Position bumper rail
no. 2
properly onto body and
cut excess length if necessary.
Slide bumper rail
no. 2
in corner bumper
no. 3
.
Install trim
no. 1
using soapy water.
Repeat procedure for the other side.
SPONSON REPLACEMENT
Removal and installation procedure for RH and LH
sponson is same.
Remove screws
no. 11.
Pry out sponson cover from back end with screw-
driver.
1. Sponson
2. Sponson cover
2
F18L3BA
1
2
4
F18L01A
3
2
1
2
F18L2BA
1
www.SeaDooManuals.net
Содержание 2003 GTI LE RFI
