— GENERAL INFORMATION
— WARRANTY / PARTS / SERVICE
— ASSEMBLY
— BATTERY CHARGING
— AFTER SPRAYING
— WINTER STORAGE
After use fill the sprayer part way with water. Start
the sprayer and allow clear water to be pumped
through the plumbing system and out through the
spray wand. Refill the tank about half full with
plain water and use a chemical neutralizer such
as Nutra-Sol® or equivalent and repeat cleaning
instructions. Flush the entire sprayer with the
neutralizing agent. Follow the chemical manu-
facturer’s disposal instructions of all wash or
rinsing water.
Drain all water and chemical out of sprayer, pay-
ing special attention to pump and valves. These
items are especially prone to damage from
chemicals and freezing weather. The sprayer
should be winterized before storage by pumping
a solution of RV antifreeze through the entire
plumbing. Proper care and maintenance will pro-
long the life of the sprayer.
— TROUBLE SHOOTING
Pump will not run:
1. Check inline fuse on the wiring harness. If
blown or damaged replace with a new 5 Amp
fuse.
2. Insure the battery is fully charged
3. Check that the on/off switch is in the on position
4. Insure that strainer located on bottom of tank
is free of debris.
5. Check wiring connections at the battery and
switch, at times these could work loose.
This unit comes fully assembled
— OPERATION
This sprayer is designed to be pulled or pushed
by hand.
Pour solution into the tank and stir to mix. For
liquid chemicals it is possible to mix by spraying
the handgun into the tank.
Turn the switch to the “ON” position and spray by
squeezing the lever on the handgun. The unit is
supplied with a demand pump that will only
operate while the lever on the handgun is
depressed.
It is recommended to charge the battery for 8-10
hours before using, or if the battery has been
stored for 6 or more months without usage. Once
fully charged you should be able to spray 40
gallons of fluid, or 8 consecutive tanks.
To charge the battery…
1. Plug the charger into a 110 Volt AC electrical
receptacle.
2. Insert the plug on the opposite end of the
charger into the charging jack located on the
back panel of the sprayer.
3. Reverse the above steps when charging is
complete.
CAUTION:
Never leave the charger connected to
the battery for more the 20 hours, as this may
damage the battery.
The purpose of this manual is to assist you in
assembling, operating and maintaining your
sprayer. Please read it carefully as it furnishes
information which will help you achieve years
of dependable trouble-free operation.
Products are warranted for one year from date of
purchase against manufacturer or workmanship
defects.
Your authorized dealer is the best source of
replacement parts and service. To obtain prompt,
efficient service, always remember to give the
following information:
1. Correct part description and part number.
2. Model number of your sprayer.
Part description and part numbers can be obtained
from the illustrated parts list section of this manual.
Whenever you need parts or repair service, contact
your distributor / dealer first. For warranty work
always take your original sales slip, or other
evidence of purchase date, to your distributor /
dealer.
PRECISION SPRAY EQUIPMENT, a divison of Green Leaf, Inc. 9490 N BALDWIN ST FONTANET, IN 47851 www.grnleafinc.com
a division of Green Leaf, Inc
®
P R E C I S I O N S P R AY E Q U I P M E N T
PSE
