Piper Cherokee LANCE, Руководство по обслуживанию

Страница: 768 / 854

PIPER CHEROKEE SIX / LANCE SERVICE MANUAL
III - INSPECTION 03/27/08
4D10
TABLE III-II. INSPECTION REPORT - PA-32R-300 (cont.)
Inspection
NATURE OF INSPECTION Interval (Hrs)
50 100
C. CABIN AND COCKPIT GROUP (CONT.)
14. Inspect gyro-operated instruments and electric turn and bank.
Overhaul or replace as required ............................................................................. O
15. Replace vacuum regulator filter ............................................................................. O
16. Inspect static system, altimeter and transponder for installation/certification
per latest revision of AC 43.13-1 and current test/inspection per
FAR’s 91.411 and 91.413, respectively ................................................................
O
17. Inspect and test ELT per FAR 91.207. (See Testing ELT, Section XI.) ................. O
18. Inspect operation of fuel selector valve ................................................................ O
19. Inspect fuel valve drain lever cover for security. Verify door opens
and closes freely and prevents operation of lever when closed ............................. O O
20. Inspect condition of heater controls and ducts....................................................... O
21. Inspect condition and operation of air vents .......................................................... O
22. If installed, inspect condition of air conditioning ducts......................................... O
23. If installed, remove and clean air conditioning evaporator filter ........................... O
24. If installed, inspect portable fire extinguisher minimum weight as
specified on nameplate........................................................................................... O
D. FUSELAGE AND EMPENNAGE GROUP
1. Remove inspection plates and panels..................................................................... O
2. Inspect aft wing attach fittings per Aft Wing Attach Fittings 100
Hour Inspection. (See Special Inspections, Procedures.).......................................
O
3. Inspect fwd baggage door, latch, and hinge for damage, operation
and security ............................................................................................................
O O
4. Inspect battery, box, and cables. Flush and clean area as required and fill battery
per instructions on box and in Electrical System, Section X .................................
O O
5. Inspect electronic installations for condition and security..................................... O
6. Inspect skins, bulkheads, frames, and stringers for damage,
irregularities, or structural defects (i.e. - skin cracks, distortion, dents,
corrosion and loose or missing rivets) (See Note 19.) ...........................................
O
7. Inspect condition and security of antennas, mounts, and wiring ........................... O
8. Check hydraulic pump fluid level. Fill as required................................................ O O
9. Inspect hydraulic pump lines for damage and leaks .............................................. O
10. If installed and operational, inspect backup landing gear extender actuator inlet
head for obstructions and contamination ............................................................... O O
11. If installed, inspect air conditioning system for refrigerant leaks. (See Note 8.)... O
12. If installed, inspect refrigerant level in sight gauge of receiver-dehydrator........... O O
13. If installed, inspect air conditioner condenser air scoop for condition and rigging.
(See Note 12.) ........................................................................................................ O O
14. Inspect fuel lines, valves, and gauges for damage and operation .......................... O
15. Remove, drain, and clean fuel strainer bowl and screen
located in the bottom of selector valve .................................................................. O O