Pioneer Eclipse CleanStar 30M, Руководство оператора

Страница: 6 / 34

CAUTION! DANGER! Crushing can occur when the
solution tank is raised for ventilation when charging the
batteries and/or to provide access to the battery
compartment for maintenance purposes. Once the
tank is raised there is no lock to prevent the tank from
being lowered. Therefore the operator or service
technician must be aware of his/her body parts while
inside the battery compartment. NEVER raise the
solution tank when it contains any fluid.
CAUTION! DANGER! Crushing and/or pinching can
occur when operating the pedals on each side of the
steering column. Use only your feet to operate the
pedals that raise/lower the scrub deck or apply the
brake.
CAUTION! DANGER! Turnover can occur when this
machine is used on grades that exceed the maximum
slope as specified in the operators manual.
CAUTION! DANGER! Turnover can occur when the
machine is used to clean broken surfaces or surfaces
with holes or deep depressions. DO NOT use the
machine on any surface that may compromise the
stability of the machine
CAUTION! DANGER! Explosion can occur while the
batteries are recharging because of hydrogen gas that
can spread. When recharging the batteries place the
machine under a well-ventilated area or under a
ventilation fan. Also keep machine away from any type
of heat source or corrosive substances while
recharging.
Amano Pioneer Eclipse is not responsible for accidents
that occur to people or things caused by the improper use
of this machine, e.g. using the machine on any surface
that can compromise its stability.
This machine is manufactured for
commercial use only.
This machine is designed and manufactured for indoor
use in scrubbing hard floor surfaces. Amano Pioneer
Eclipse does not recommend use of this machine in any
environment other than an indoor environment.
Amano Pioneer Eclipse battery powered floor machines
are designed and manufactured for commercial floor
maintenance only. This machine is designed to scrub
most modern types of floors including composition tile,
stone, marble, terrazzo, and resilient floor covering, and
some coated wood floors.
Improper Use of CleanStar 30M
Scrubber
z
This machine cannot be driven by unauthorized
personnel.
z
This machine cannot be used to clean sloped
surfaces with a grade over 5%.
z
This machine cannot exceed a reverse speed of
.6mph (1km/hr) when used to clean floors.
z
This machine cannot be used in an area that has
dangerous substances, flammable gas, flammable
liquid, or any type substance with an explosive nature
in close proximity.
z
This machine cannot use flammable and/or explosive
products to clean surfaces.
z
This machine cannot be used as a means of
transportation, for people and other means of
transport.
z
Do not remove, modify, or tamper with the safety and
protection devices on this machine.
z
Batteries must be charged in a well ventilated room.
z
The operator must always obey all of the safety rules
written in this manual.
z
The operator cannot use any equipment or other
device that can cause or prevent this machine from
working properly.
z
The components on this machine cannot be modified
without authorization from Amano Pioneer Eclipse or
an Authorized Distributor.
z
The operator cannot use acids that can damage this
machine.
z
This machine cannot be used as a tractor to tow or
push.
Operator Responsibility
The operator is responsible for performing the
recommended daily maintenance and checkups of the
machine to keep it in good working condition. The
operator must inform the service mechanic or supervisor
when recommended maintenance procedures are required
as proscribed in the MAINTENANCE section of this
manual.
Read this manual carefully before operating this machine.
4