3
5.
PCCU-100 IS RATED FOR 115 VAC 60 Hz OPERATION
. Use the
inverter only to power appropriate appliances rated for this power input .
6.
PCCU-100 IS RATED TO POWER LOADS OF 50 WATTS
CONTINUOUS
. Do not connect high power loads (> 50 W) to your
inverter.
7. TO REDUCE USE OF ELECTRIC SHOCK
always unplug any
appliances from the PCCU-100 and remove the battery pack from the
inverter before cleaning or maintaining the inverter or any appliance.
Use of a Ground Fault Circuit Interrupter between the inverter output and
the appliance is recommended to reduce shock hazards.
8. DO NOT DISASSEMBLE
. The PCCU-100 contains no user
serviceable parts and should not be disassembled under any
circumstances. If faulty operation is suspected, return the inverter for
inspection and service if required.
9.
NEVER CONNECT THE PCCU-100 TO AC DISTRIBUTION
WIRING
. Connect the 115 VAC inverter output directly to the appliance
to be powered, preferably using a GFCI power cord / module.
10.
STORE INVERTER IN A COOL, DRY PLACE
. Avoid leaving the
inverter in direct sunlight, vehicle cabs, compartments, or unventilated
storage buildings during hot summer conditions. Under extreme
temperature conditions damage may occur. Avoid allowing inverter to
become wet or damp. Allow damp or wet inverter to dry thoroughly
before using.
11.
TURN PCCU-100 OFF AND REMOVE BATTERY PACK
when not
in use.
12.
REPLACE FUSE ONLY WITH 10A 32V BLADE FUSE.
WARNING
READ AND SAVE THESE INSTRUCTIONS FOR
FUTURE USE.
Failure to follow all instructions may result in electrical shock, fire,
equipment damage, and/or serious personal injury.
4
FUNCTIONAL DESCRIPTION
If a battery pack is too hot or too cold, it will not power the PCCU-100
module. The lighted on/off power switch will illuminate when turned to
the on position with a charged battery within temperature limits attached.
If the switch does not illuminate, check that the fuse is intact and that the
battery does not show an error condition when connected to a CHG-50
charger. If the switch still does not illuminate, the PCCU-100 should be
retired from service and sent for inspection and repair if needed.
LIGHTED POWER
ON/OFF SWITCH
115 VAC 60 Hz
POWER
RECEPTACLE
FUSE
BATTERY
CONNECTOR
INFORMATION
LABEL
(NOT VISIBLE)
PCCU-100
24 Volt
Lithium Ion
Battery
to 115 VAC 60 Hz
Power Conversion and Control Unit
